The 2006 Outback is a capable AWD wagon undermined by catastrophic head gasket failures on the 2.5L and significant transmission cooler issues. The 3.0L H6 is far more reliable but thirsty and harder to find.
Head Gasket Failure (2.5L Engines)
Common · high severity
Typical onset: 80,000-150,000 mi
Symptoms: External oil seepage at block/head mating surfaces, White exhaust smoke on cold start, Coolant loss with no visible leaks, Overheating under load, Milky residue on oil cap
Fix: Both head gaskets must be replaced; machine heads if warped. Timing belt, water pump, and cam/crank seals done simultaneously. 12-16 labor hours at indie shops. This is not preventable—it's a design flaw in the EJ25 gasket material and block deck finish.
Estimated cost: $2,200-3,500
Transmission Oil Cooler Line Corrosion
Common · high severity
Typical onset: 100,000-180,000 mi
Symptoms: Pink fluid puddle under vehicle (ATF mixing with coolant), Transmission overheating or slipping, Milky transmission fluid on dipstick, Coolant level dropping
Fix: Corroded cooler lines inside radiator contaminate ATF with coolant, destroying the transmission. Requires radiator replacement and complete ATF flush minimum; if contamination reached trans internals, expect full rebuild or replacement. 3-5 hours for radiator alone, 15-20+ if trans needs work.
Symptoms: Engine stalls while driving, Accessories cut out intermittently, Key won't turn or gets stuck, No crank/no start
Fix: NHTSA recall 10V388000—ignition switch can overheat and fail, causing stall. Dealer replacement takes 1-2 hours. Check if prior owner completed recall; if not, dealer may still cover it.
Symptoms: Growling or humming noise that increases with speed, Noise changes pitch in turns, Vibration through steering wheel, ABS or traction light occasionally triggers
Fix: Hub assemblies are pressed-in and require special tooling. 2-3 hours per side. Not dangerous immediately but will grenade if ignored, risking wheel lockup.
Estimated cost: $350-550 per side
Rear Differential Carrier Bushing Wear
Occasional · low severity
Typical onset: 120,000-180,000 mi
Symptoms: Clunk on acceleration or deceleration, Vibration from rear on highway, Whining from rear diff under load
Fix: Rubber carrier bushings fatigue and allow diff to shift. Requires rear subframe or diff removal to press new bushings. 4-6 hours labor. Often ignored until catastrophic failure.
Estimated cost: $600-950
Timing Belt and Water Pump (Interference Engine)
Common · high severity
Typical onset: 105,000 mi intervals (or 7 years)
Symptoms: No symptoms until catastrophic failure, Squealing from belt area if severely worn
Fix: EJ25 is interference—if belt snaps, valves meet pistons and destroy the engine. Factory interval is 105k but many techs recommend 90k in rust-belt states. Always replace water pump, tensioners, idlers, and seals at same time. 6-8 hours labor.
Estimated cost: $800-1,300
Catalytic Converter Failure (2.5L)
Occasional · medium severity
Typical onset: 120,000-180,000 mi
Symptoms: Check engine light P0420 or P0421, Rotten egg smell, Loss of power on hills, Failed emissions test
Fix: Upstream cats (pre-cat in manifold) can fail internally, causing backpressure and damaging downstream O2 sensors. OEM cats require manifold replacement; aftermarket options exist but fitment is tight. 3-4 hours per side.
If buying used, verify head gasket service history on 2.5L—expect it to need doing if no records exist above 100k miles.
Inspect transmission fluid color immediately; pink or milky means cooler line failure has started—walk away.
The 3.0L H6 avoids head gasket issues but requires timing belt service and gets 18-20 mpg combined.
Change rear diff fluid every 30k with 75W-90 GL-5 to extend carrier bearing life.
Use Subaru-specific coolant (blue) to minimize head gasket corrosion; green universal coolant accelerates failure.
Buy a 3.0L H6 if you can find one; otherwise budget $3k-5k for inevitable head gaskets and trans cooler work on the 2.5L within 20k miles of purchase.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2006 Subaru Outback
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V001000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (STI included), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators with alternate inflators, free of charge. The recall began January 7, 2020. Subaru Owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKA-20.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V002000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKB-20.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V003000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKC-20.
ELECTRICAL SYSTEM:IGNITION:SWITCH · 19V297000
2019-04-11
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester vehicles, 2008-2011 Impreza vehicles, 2008-2014 WRX vehicles, 2005-2014 Legacy vehicles, 2005-2014 Outback vehicles and 2006-2008 Tribeca vehicles equipped with a mechanical key ignition switch installed as a replacement part. The ball spring inside the switch may break, reducing the strength of the ignition switch. If this occurs, the weight on the key ring and certain road conditions could cause the ignition switch to move out of the run position to the accessory position, turning off the engine.
Consequence: The engine turning off unexpectedly can increase the risk of a crash. If a crash occurs under this condition, the air bag may not deploy, increasing the risk of injury.
Remedy: Subaru will notify owners, and dealers will inspect the ignition switch, replacing the ignition switch, if necessary, free of charge. The recall began May 10, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUF-91.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 15V323000
2015-05-28 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Subaru Baja vehicles manufactured January 22, 2003, to July 21, 2004, 2004-2005 Impreza vehicles manufactured January 28, 2003, to May 31, 2005, 2003-2008 Subaru Legacy vehicles manufactured January 22, 2003, to May 2, 2008, 2003-2008 Subaru Outback vehicles manufactured February 18, 2003, to May 5, 2008, and 2005 Saab 9-2x vehicles manufactured February 11, 2004, to March 17, 2005. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture upon its deployment.
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Subaru will notify their owners and General Motors will notify Saab owners. Dealers will replace the passenger air bag inflator, free of charge. The Subaru recall began on June 17, 2015. Owners may contact Subaru customer service at 1-800-782-2783. The Saab recall began on July 27, 2015. Owners of Saab vehicles may call 1-800-955-9007. Subaru's number for this recall is WQR-53. Note: The recall completely supersedes recall 14V-399 (WQL-48) and partially supersedes recall 14V-763 (WQP-51) in that model year 2004 through 2005 Subaru Impreza and model year 2005 Saab 9-2x vehicles are now only part of this campaign. Note: On December 18, 2015 Subaru informed NHTSA of an expansion of this recall to include certain model year 2003-2004 Subaru Baja, 2003-2008 Subaru Legacy and 2003-2008 Subaru Outback vehicles.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS · 14V311000
2014-06-10
Subaru of America, Inc. (Subaru) is recalling certain model year 2005-2009 Outback and Legacy, 2008-2011 Impreza and 2008-2014 Impreza WRX/STI, and 2009-2013 Forester vehicles, currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.
Note that affected vehicles not currently, or formerly registered, in the salt belt states identified above are eligible for repair, at no cost to the customer, upon request.
Consequence: Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Remedy: Subaru will notify owners, and dealers will test the brake system by depressing the brake pedal and inspecting for brake fluid leaks. If no brake fluid seepage is observed, the affected areas will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began July 2014 and second notifications will run through November 2014. Owners may contact Subaru at 1-800-782-2783. Subaru's recall campaign number is WQK-47. Note: This recall supersedes recall 13V-110 which applied to certain 2005-2009 Legacy/Outback vehicles. Vehicles that were remedied under the previous campaign still need additional areas rust-proofed.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS · 13V110000
2013-03-27
Subaru is recalling certain model year 2005-2009 Outback and Legacy vehicles manufactured from December 2003, through April 2009 and currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.
Consequence: Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Remedy: Subaru will notify owners, and dealers will inspect the vehicles. If no brake fluid seepage is observed, the affected area will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began on May 30, 2013. Owners may contact Subaru at 1-800-782-2783. Subaru's recall campaign number is WQG-43.
Building an app?
Free API access to all this data — 50 requests/day, no card required.