The 2019 Model 3 is generally reliable for an early-generation EV, but suffers from specific drivetrain mount failures, HVAC system weaknesses, and some high-voltage component issues that can be expensive when they occur outside warranty.
Rear Drive Unit Motor Mounts Failure
Common · medium severity
Typical onset: 40,000-80,000 mi
Symptoms: Clunking or thunking noise from rear on acceleration or deceleration, Vibration through floorboard especially during regen braking, Excessive drivetrain movement visible under car during hard launches
Fix: Requires lifting vehicle and replacing rear motor mounts, typically both sides done together. 2.5-3.5 hours labor. Tesla updated the part design mid-2019 but early cars got weaker mounts.
Estimated cost: $800-1,200
Drive Unit (Motor/Inverter Assembly) Failure
Occasional · high severity
Typical onset: 60,000-120,000 mi
Symptoms: Whining, grinding, or humming noise from motor that increases with speed, Reduced power or limp mode warnings on screen, Drive unit overheating alerts, Complete loss of propulsion in severe cases
Fix: Entire drive unit replacement required—no individual motor rebuilds available. Rear unit 6-8 hours, front unit (AWD) 8-10 hours. Tesla often replaces under goodwill even out of warranty due to prevalence. Fluid contamination or bearing failures most common.
Estimated cost: $7,000-12,000
AC Evaporator Coil Corrosion/Leak
Occasional · medium severity
Symptoms: Weak or no cold air from climate system, Musty smell from vents, Refrigerant low warning or AC system fault, Condensation puddles inside cabin near footwells
Fix: Requires complete dash removal to access evaporator—one of the worst jobs on this car. 12-16 hours labor. Design flaw allowed road salt and moisture intrusion. Tesla issued TSB but no recall.
Estimated cost: $2,500-4,000
High Voltage Battery Coolant Leaks
Occasional · high severity
Typical onset: 50,000-90,000 mi
Symptoms: Orange/pink coolant puddles under vehicle center, Battery heating/cooling system fault messages, Reduced charging speed or range, Battery temperature warnings especially in extreme weather
Fix: Usually failed quick-disconnect fittings or cracked coolant lines at battery pack. Minor leaks can be fixed without pack removal (3-5 hours), but internal pack leaks require full battery drop and module work (15-20+ hours). Coolant is expensive specialized glycol blend.
Estimated cost: $1,200-8,000
12V Battery Premature Failure
Common · medium severity
Typical onset: 30,000-60,000 mi
Symptoms: Car won't wake up or unlock via app or key card, Warning to replace 12V battery soon on screen, Accessories not working when parked, Frunk won't open electrically
Fix: Early cars used undersized lead-acid 12V batteries that fail much sooner than expected. Replacement is straightforward but requires removing front undertray and service mode activation. 1-1.5 hours. Later TSB upgraded to lithium 12V.
Estimated cost: $300-500
Touchscreen MCU (Media Control Unit) Yellowing/Failure
Occasional · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: Screen edges turning yellow or brown, Touchscreen unresponsive or laggy, Backup camera not displaying or freezing, Random reboots while driving
Fix: 2019 cars came with MCU2 which uses eMMC memory that wears out. Tesla offered upgrade program to MCU3 ($1,500 from Tesla). Indie shops can replace MCU assembly in 2-3 hours but requires configuration and software.
Estimated cost: $1,500-2,500
Charge Port Door and Latch Failures
Common · low severity
Symptoms: Charge port won't open when pressed or via screen, Door stuck open and won't close, Charging cable won't lock or unlock from port, Charge port light not illuminating
Fix: Usually actuator motor or latch mechanism inside door. Access from behind rear light assembly. 1.5-2 hours labor. Cold weather and frequent use accelerate wear. Some early cars had revised latch TSB.
Estimated cost: $400-700
Owner tips
Change drive unit fluid every 50,000 miles despite Tesla saying 'lifetime'—it's cheap insurance against $10k motor replacements
Keep an eye on your 12V battery health in the service menu; replace proactively around 3 years even if no warning yet
If you live in salt states, rinse underbody regularly and consider annual HVAC evaporator treatment to prevent corrosion
Budget $1,500-2,000/year for out-of-warranty surprises on 2019 models—they're past the 4yr/50k basic warranty sweet spot now
Buy if under 60k miles with service records showing drive unit fluid changes and 12V battery replacement; avoid high-mileage AWD cars without extended warranty coverage for drivetrain.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2019 Tesla Model 3
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS · 24V935000
2024-12-17
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence: Driving with improperly inflated tires increases the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Consequence: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Consequence: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
SUSPENSION:FRONT · 23V235000
2023-03-31
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
Consequence: A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
STEERING:AUTOMATED/ADAPTIVE STEERING · 23V085000
2023-02-15 · EA22002
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
Consequence: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
SEAT BELTS:REAR/OTHER:ANCHORAGE · 22V798000
2022-10-21
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat
belt anchor may have been incorrectly reassembled during vehicle service.
Consequence: An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Remedy: Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS · 22V702000
2022-09-19
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
Consequence: A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Remedy: Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence: The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
ELECTRICAL SYSTEM:SOFTWARE · 22V235000
2022-04-12
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
BACK OVER PREVENTION:DISPLAY FUNCTION · 22V169000
2022-03-18
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
ELECTRICAL SYSTEM:SOFTWARE · 22V063000
2022-02-04 · DP22005
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
ELECTRICAL SYSTEM:SOFTWARE · 22V045000
2022-02-01
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Consequence: Failing to stop at a stop sign can increase the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
Consequence: A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Remedy: Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA · 21V846000
2021-10-29
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Consequence: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
SUSPENSION:CRITICAL FASTENERS · 21V835000
2021-10-25
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
Consequence: A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER · 21V387000
2021-05-25
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Consequence: Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Remedy: Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
SEAT BELTS · 21V389000
2021-05-25
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
Consequence: An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Remedy: Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
EQUIPMENT:OTHER:LABELS · 19V719000
2019-10-10
Tesla Motors, Inc. (Tesla) is recalling certain 2019 Tesla Model 3 vehicles. The driver-side sun visor may not have the required air bag warning information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence: Failure to provide the air bag warning information increases the risk of injury.
Remedy: Tesla will notify owners, and Tesla Service Centers will inspect the visor and replace it, as necessary, free of charge. The recall began December 6, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-19-15-003.
Building an app?
Free API access to all this data — 50 requests/day, no card required.