The 2022 Bronco is still shaking out early production gremlins, with the 2.7L V6 EcoBoost showing catastrophic engine failures and transmission cooling issues appearing across all powertrains. These are low-mileage problems — many happen under warranty, but post-warranty owners face brutal repair bills.
Symptoms: sudden loss of power, severe engine knock, metal shavings in oil, check engine light with multiple misfires, complete engine seizure
Fix: Valve drops into cylinder, destroying pistons, rods, and crank. Requires complete engine rebuild or replacement. 18-24 hours labor for short block swap, plus machine work if salvaging heads. Ford has extended warranty coverage on some VINs, but many owners hit this post-warranty.
Estimated cost: $8,000-15,000
Transmission Oil Cooler Failure / Leaking
Common · high severity
Typical onset: 15,000-50,000 mi
Symptoms: transmission fluid dripping from cooler lines, burnt transmission fluid smell, harsh shifting when hot, transmission overheating warnings, puddles under vehicle
Fix: 10-speed transmission runs hot in off-road use, cooler lines crack or fittings leak at crimps. Replace cooler assembly and lines, flush transmission. 3-4 hours labor. Some cases need full transmission replacement if overheated severely before caught.
Estimated cost: $800-1,200
Backup Camera System Failure
Common · medium severity
Symptoms: blank screen when shifting to reverse, intermittent camera display, camera guidelines missing or frozen, SYNC screen shows 'camera unavailable'
Fix: Water intrusion into rear camera housing or wiring harness corrosion at tailgate. Multiple recalls issued but problems persist. Replace camera module and seal properly, or replace tailgate harness if corroded. 1.5-2 hours labor.
Estimated cost: $400-700
2.3L EcoBoost Head Gasket Failure
Occasional · high severity
Typical onset: 30,000-70,000 mi
Symptoms: white smoke from exhaust on cold start, coolant loss with no visible leak, rough idle when warm, oil in coolant reservoir, overheating under load
Fix: Head gasket fails between cylinders or into coolant passage. Requires head removal, machining if warped, new gasket set, timing service while apart. 12-16 hours labor. Check head for cracks — some need replacement.
Estimated cost: $3,500-5,500
Transmission Mount Failure
Common · low severity
Typical onset: 20,000-60,000 mi
Symptoms: clunking when shifting from park to drive, vibration at idle in gear, excessive driveline movement felt through floor, visible torn rubber on transmission mount
Fix: Rubber mount tears from aggressive off-road use or repeated hard launches. Replace transmission mount, sometimes need transfer case mount too. 2-3 hours labor with lift access.
Estimated cost: $400-650
Soft-Top Latching and Water Intrusion
Common · low severity
Symptoms: wind noise at highway speeds, water leaking at A-pillar or rear corners, latches not fully engaging, fabric sagging between bows, mold smell inside cabin
Fix: Soft-top owners fight constant adjustment. Latches need periodic re-tensioning (15 minutes per corner), weatherstripping replacement every 2-3 years in wet climates. Not a safety issue but annoying. 1-2 hours for full weatherstrip replacement.
Estimated cost: $200-500
Fuel Pump Failure (Recall-Related)
Occasional · high severity
Typical onset: 10,000-40,000 mi
Symptoms: no-start condition, engine stalling at idle or low speed, extended cranking before start, loss of power under acceleration, fuel pressure fault codes
Fix: Bosch fuel pump impeller cracks, causing low pressure. Covered under recall but still happens. Drop tank, replace fuel pump module. 3-4 hours labor. Check for recall completion before buying used.
Estimated cost: $800-1,200
Owner tips
Change transmission fluid every 30,000 mi if off-roading or towing — factory 'lifetime' fill is optimistic for how these are used
2.7L engines: check oil consumption every 1,000 mi in first 50k — early warning sign of valve issues
Inspect transmission cooler lines every oil change for seepage or cracking at fittings
Verify all recall work completed with Ford before purchase — fuel pump and camera recalls are critical
Wait for 2024+ model year if buying — too many early production issues still surfacing on 2021-2022 builds, and post-warranty engine failures are financially catastrophic.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2022 Ford Bronco
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.
Consequence: Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Interim letters, notifying owners of the safety risk, are expected to be mailed April 27, 2026. Additional letters will be sent once the remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
BACK OVER PREVENTION:SOFTWARE · 26V124000
2026-03-03
Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.
Consequence: A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 25V888000
2025-12-18
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were previously repaired incorrectly under recall number 23V165. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Remedy: Dealer will update the SYNC module software ,free of charge. Owner notification letters were mailed January 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C72. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 30, 2026.
SEATS:CRITICAL FASTENERS · 25V721000
2025-10-23
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.
Consequence: A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy: Dealers will replace the pivot links and bolts, free of charge. Interim letters, notifying owners of the safety risk, were mailed November 6, 2025. Additional letters will be sent once the final remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB5. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 28, 2025.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence: An engine stall increases the risk of a crash.
Remedy: The remedy is under development. Interim notification letters notifying owners of the safety risk were mailed July 16, 2025. Second letters will be sent once the remedy is available, anticipated 2nd Quarter 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 25V273000
2025-05-14
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco vehicles. The 360-degree view camera may not display a rearview image when the vehicle is placed in reverse.
Consequence: Loss of the rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed October 8, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 23S48. This recall expands previous recall number 23V-598.
BACK OVER PREVENTION:SOFTWARE · 25V315000
2025-05-14
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 25V312000
2025-05-09
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were repaired incorrectly under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Remedy: Dealers will update SYNC module software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C14.
SUSPENSION:REAR:SHOCK ABSORBER · 25V025000
2025-01-17
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco vehicles. The rear shock absorbers may corrode and fail, resulting in detachment of the external reservoir.
Consequence: An external reservoir that detaches from a vehicle can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will replace the rear shock absorbers, as necessary free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S01.
ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL · 24V635000
2024-08-23 · EA23002
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
EQUIPMENT:OTHER:LABELS · 23V379000
2023-05-26
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.
SEAT BELTS:CRITICAL FASTENERS · 23V358000
2023-05-18
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles built with the 5-Door body style. The first-row seat belt latch plates may be difficult to access from their stowed position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: Difficulty accessing the seat belt latches may result in occupants not wearing their seat belts, increasing the risk of injury in a crash.
Remedy: Dealers will add a sliding clip latch stop to the driver and front passenger seat belts, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed July 14, 2023. Owner letters informing owners that parts are available were mailed on October 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C16.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 23V165000
2023-03-10
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were previously remedied under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Remedy: The SYNC module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on March 28, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C05.
STEERING · 23V155000
2023-03-08
Ford Motor Company (Ford) is recalling certain 2023 Bronco Wildtrak and 2022 Bronco Raptor vehicles. Internal damage to the steering gear may require increased steering effort or cause the steering wheel to lock-up.
Consequence: A steering wheel that locks-up can result in a complete loss of steering control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Dealers will replace the steering gear, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S09.
POWER TRAIN:AUTOMATIC TRANSMISSION · 23V070000
2023-02-10
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."
Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.
AIR BAGS:SENSOR:SIDE IMPACT · 22V928000
2022-12-14
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles. The right or left side impact sensors may not be properly secured to the vehicle.
Consequence: An improperly secured side impact sensor may cause the air bags to unintentionally deploy, or not to deploy as intended, increasing the risk of injury in a crash.
Remedy: Dealers will inspect the side impact sensor attachments and repair, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S77.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 22V825000
2022-11-03
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with rearview camera systems and 8-inch screen displays. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Remedy: The SYNC module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on March 25, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C27.
VISIBILITY:WINDSHIELD · 22V451000
2022-06-24
Ford Motor Company (Ford) is recalling certain 2022 Bronco and Ranger vehicles. The windshield may not have been properly bonded to the vehicle, which could allow it to detach during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 212, "Windshield Mounting."
Consequence: A windshield that separates from a vehicle during a crash can increase the risk of injury.
Remedy: Dealers will remove and reinstall the windshield, free of charge. Owner notification letters were mailed July 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C12.
LATCHES/LOCKS/LINKAGES:DOORS:LOCK · 22V411000
2022-06-10
Ford Motor Company (Ford) is recalling certain four-door 2021-2022 Bronco vehicles. The passenger-side rear door may be opened from inside of the vehicle when the child safety lock is in the "ON" position.
Consequence: A malfunctioning child safety lock increases the risk of injury to a child occupant.
Remedy: Dealers will inspect the passenger-side child safety locks door child safety lock and latch, and replace them, if necessary, free of charge. Owner notification letters were mailed June 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S44.
Building an app?
Free API access to all this data — 50 requests/day, no card required.