The 2022 E-350 is Ford's full-size van workhorse built on a decades-proven chassis. While still relatively new, we're seeing early patterns emerge — mostly powertrain-related on higher-mileage commercial units and a steering hydraulic issue covered by recall.
7.3L Godzilla Piston Ring / Bore Scoring Issues
Occasional · high severityTypical onset: 30,000-80,000 mi
Symptoms: Excessive oil consumption — 1 qt per 1,000-1,500 miles, Blue smoke on startup or under load, Loss of compression, rough idle, Check engine light with cylinder misfire codes
Fix: Ring replacement requires full teardown. In severe cases, cylinder honing or bore repairs needed. 18-25 hours labor for rings alone; if bore is scored, short block replacement at 22-28 hours is more common fix. This is an early-life issue likely tied to break-in abuse or manufacturing tolerance stacking.
Estimated cost: $6,500-12,000
Transmission Oil Cooler Line Leaks
Common · medium severityTypical onset: 40,000-90,000 mi
Symptoms: Transmission fluid puddles under front of vehicle, Burned transmission fluid smell, Slipping shifts or delayed engagement when fluid level drops, Pink or red fluid visible along cooler lines or radiator
Fix: 10R140 transmission cooler lines fail at crimp fittings or corrode at frame contact points. Replacement involves dropping lines, flushing cooler, topping fluid. 2.5-4 hours labor depending on which line. Always inspect both even if only one is leaking.
Estimated cost: $450-850
Hydraulic Power Steering Hose Failures (NHTSA Recall)
Occasional · high severitySymptoms: Power steering fluid leak from high-pressure hose near pump, Loss of power assist — heavy steering effort, Whining or groaning from pump, Fluid spray visible in engine bay, fire risk if contacts hot exhaust
Fix: Ford recall 23S13 and 23V479 cover defective hose crimps that can rupture. Recall repair replaces pressure hose assembly. If out of recall eligibility or already failed, hose replacement is 1.5-2.5 hours. Do NOT drive with failed hose — fire hazard is real.
Estimated cost: $350-650
Transmission Mount Deterioration
Common · low severityTypical onset: 50,000-100,000 mi
Symptoms: Clunk on hard acceleration or deceleration, Vibration felt through floor at idle in gear, Visible sagging or cracking of rubber mount, Excessive driveline movement when shifting from park to drive
Fix: The rear transmission mount wears quickly on commercial vans due to load and stop-and-go driving. Replacement is straightforward — support transmission, unbolt mount, swap. 1-1.5 hours labor. Check engine mounts at same time if vibration persists.
Estimated cost: $250-450
Fuel Tank Strap Corrosion (NHTSA Recall)
Rare · high severitySymptoms: Fuel tank sagging or hanging low, Visible rust or cracking on steel tank straps, Fuel smell from underneath vehicle, Tank may separate from vehicle in extreme cases
Fix: Ford recall 22V740 addresses tank straps that corrode prematurely in salt-belt states. Recall replaces both straps. If you're in rust country and straps weren't replaced, inspect annually. Aftermarket strap replacement is 1.5-2 hours labor but requires tank drop.
Estimated cost: $400-700
6.8L V10 Triton Spark Plug Blowout (Carryover Issue)
Occasional · medium severityTypical onset: 60,000-120,000 mi
Symptoms: Sudden loud pop or hissing sound from engine bay, Misfire code for specific cylinder, Loss of power, rough running, Spark plug ejected from head or cross-threaded in bore
Fix: The 3-valve Triton still uses the weak thread design. Blowouts damage threads in aluminum head. Helicoil or Time-Sert thread repair is 3-5 hours depending on cylinder access. Always torque plugs to spec and replace at 60k intervals preventively.
Estimated cost: $800-1,400
Solid commercial platform if you avoid early 7.3L oil-consumption units and stay on top of transmission maintenance; recalls are handled, but check VIN before buying used.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.