The 2024 Santa Fe is still too new for meaningful long-term failure data, but the platform shares DNA with prior-gen models showing turbo engine issues and transmission control gremlins. Early recalls focus on electrical and software problems typical of modern Hyundai launches.
2.5L Turbo Engine Bearing and Piston Failures
Occasional · high severity
Typical onset: 40,000-80,000 mi
Symptoms: Metallic knocking from engine bay, especially cold start, Metal shavings in oil during changes, Loss of oil pressure warning, Catastrophic seizure if ignored
Fix: Complete engine rebuild or short block replacement required. Hyundai has extended warranties on some prior turbo engines for this exact issue—check TSBs. Expect 18-25 labor hours for short block swap, more for full teardown rebuild.
Estimated cost: $6,500-11,000
8-Speed Automatic Transmission Control Module Software Issues
Common · medium severity
Symptoms: Harsh shifting between 2nd-3rd gears, Delayed engagement from Park to Drive, Check engine light with P0700/P0868 codes, Transmission enters limp mode randomly
Fix: Usually resolved with TCM software reflash per TSB, though some units need valve body replacement if reflash doesn't hold. Reflash is 1.5 hours, valve body is 8-10 hours if transmission stays in vehicle.
Estimated cost: $150-2,800
Transmission Oil Cooler Line Leaks
Occasional · medium severity
Typical onset: 50,000-90,000 mi
Symptoms: Transmission fluid puddles under front of vehicle, Burnt transmission fluid smell, Slipping or overheating warnings on dash, Pink fluid visible near radiator area
Fix: Cooler lines crack at crimp points or cooler itself develops pinhole leaks. Requires line replacement and system flush. 3-4 hours labor depending on access.
Estimated cost: $450-850
Starter Motor Failure (Recall 24V-583)
Occasional · high severity
Symptoms: No crank, single click when key turned, Intermittent no-start that becomes permanent, Dash lights work but engine won't turn over
Fix: Factory recall for starter assembly—should be free at dealer. If out of warranty period or recall not applied, aftermarket starter replacement takes 2-3 hours on the turbo models (tight access).
Estimated cost: $0 (recall) or $550-900
Backup Camera Display Glitches (Recall 24V-701)
Common · low severity
Symptoms: Backup camera shows black screen or freezes, Delayed image display when shifting to Reverse, Warning chime sounds but no visual
Fix: Software update to infotainment system, typically 1 hour at dealer. Covered under recall. Rarely a camera module hardware failure requiring replacement (add 2 hours).
Estimated cost: $0 (recall) or $400-650
Front Seat Belt Anchorage Issues (Recall 24V-653)
Rare · high severity
Symptoms: Seat belt anchor point feels loose or rattles, Visible movement at B-pillar mounting point, Increased slack in belt during normal use
Fix: Factory recall for improperly torqued mounting bolts—dealer inspection and re-torque procedure, 0.5-1 hour. Critical safety item, get it done immediately.
Estimated cost: $0 (recall)
Owner tips
Change engine oil every 5,000 miles or less on turbo models—these engines are unforgiving with extended intervals
Check transmission fluid color at every oil change; dark or burnt smell means get it serviced immediately
Run all recall checks by VIN before purchase—the 2024s have several active campaigns
Avoid extended idle times with turbos; let engine run 30 seconds before shutdown after highway driving
Too early to recommend used—wait until 2026+ to see if the turbo bearing issues plaguing older Hyundai mills show up here, and let the recalls get sorted.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2024 Hyundai Santa Fe
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
Hyundai Motor America (Hyundai) is recalling certain 2023-2025 Hyundai Ioniq 6, 2023-2026 Genesis G90, 2024-2026 Hyundai Santa Fe, and Hyundai Santa Fe Hybrid vehicles. The driver and passenger seat belt anchors may detach.
Consequence: A detached seat belt anchor will not adequately restrain the seat occupant, increasing the risk of injury in a crash.
Remedy: Dealers will inspect and reinforce or replace the seat belt anchors, as necessary, free of charge. Owner notification letters are expected to be mailed June 5, 2026. Owners may contact Hyundai customer service at 1-855-371-9460 and Genesis customer service at 844-340-9741. Hyundai's numbers for this recall are 298 and 032G. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov April 8, 2026.
BACK OVER PREVENTION:DISPLAY FUNCTION · 25V808000
2025-11-21
Hyundai Motor America (Hyundai) is recalling certain 2024-2025 Santa Fe and Santa Fe Hybrid vehicles. The rearview camera may not have been installed properly, which can damage the wiring harness and cause the rearview camera image not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A rearview image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the camera wiring harness, free of charge. Owner notification letters were mailed beginning January 15, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 288. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 22, 2025.
ELECTRICAL SYSTEM:STARTER ASSEMBLY · 25V659000
2025-10-02
Hyundai Motor America (Hyundai) is recalling certain 2024-2025 Santa Fe vehicles. The B+ positive terminal cover on the starter motor assembly may be improperly installed, which can cause an electrical short during a crash.
Consequence: An electrical short increases the risk of a fire.
Remedy: Dealers will inspect and reinstall the starter motor terminal cover, as necessary, free of charge. Owner notification letters were mailed beginning October 22, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 285. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 4, 2025.
Hyundai Motor America (Hyundai) is recalling certain 2024 Santa Fe and Santa Fe Hybrid vehicles. The overhead console rear sunshade switch knob may not be fully recessed, which can result in unintentional closing of the sunshade. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window, Partition and Roof Panel Systems."
Consequence: A sunshade that closes unexpectedly can increase the risk of injury.
Remedy: Dealers will replace the switch knobs, free of charge. Owner notification letters were mailed December 2, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 270.
AIR BAGS · 24V561000
2024-07-26
Hyundai Motor America (Hyundai) is recalling certain 2024 Santa Fe and Santa Fe HEV vehicles. The main floor wiring harness may chafe against the passenger-side second-row bench seat assembly and become damaged, which can cause the air bags to deploy unintentionally or prevent the air bags from deploying in a crash.
Consequence: An air bag that deploys unintentionally can increase the risk of an injury. An air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will inspect and repair, or replace the wiring harness as necessary, free of charge. Owner notification letters were mailed August 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 265.
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE · 24V529000
2024-07-12
Hyundai Motor America (Hyundai) is recalling certain 2024 Santa Fe vehicles. A software error in the transmission control unit may result in a vehicle roll away when the vehicle is in PARK.
Consequence: A vehicle roll away increases the risk of a crash or injury.
Remedy: Owners are advised to use the emergency parking brake after parking their vehicles. Hyundai will release an over-the-air (OTA) software update for the transmission control unit. In addition, dealers will inspect and replace the dual clutch transmission, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed beginning August 26, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 263.
BACK OVER PREVENTION:SOFTWARE · 24V246000
2024-04-02
Hyundai Motor America (Hyundai) is recalling certain 2024 Santa Fe vehicles. The rearview camera image may be obstructed by a trailer parking assist message. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image reduces rearward visibility and increases the risk of a crash or injury.
Remedy: Hyundai will release an over-the-air (OTA) software update. Owner notification letters were mailed beginning May 31, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 258.
Building an app?
Free API access to all this data — 50 requests/day, no card required.