The 2020 Lincoln Aviator shares the CD6 platform with the Explorer and uses Ford's 3.0L twin-turbo V6 (gas or PHEV). Early examples have shown serious engine reliability issues tied to defective cylinder liners, plus typical Ford infotainment and backup camera glitches covered by recalls.
Symptoms: Severe oil consumption (quart per 500-1000 miles), White or blue smoke from exhaust on startup or acceleration, Metallic knocking or rattling from engine under load, Check engine light with misfire codes P0300-P0306, Loss of power, rough idle, or complete engine seizure in worst cases
Fix: Ford has issued TSB 21-2327 for cylinder liner separation causing piston scuffing and ring damage. Repair requires complete engine teardown with new pistons, rings, liners, and often crankshaft/bearings if metal contamination occurred. Many cases end up being full long-block replacements. Labor runs 18-28 hours depending on whether it's a rebuild or R&R swap. PHEV models add complexity removing battery pack for access.
Estimated cost: $8,000-15,000
Backup Camera System Failure and Software Glitches
Common · medium severity
Symptoms: Backup camera shows black screen, frozen image, or 'camera unavailable' message, Delayed camera activation when shifting to reverse (3-10 second lag), Distorted or pixelated rear view display, Parking sensors give false alerts or fail to activate
Fix: Multiple recalls (20S42, 21S23, 22S47) address camera and sensor software. Dealer reflash takes 0.5-1.0 hours and is often covered under recall. Physical camera failures require tailgate trim removal and camera replacement, about 1.5 hours labor. Independent shops can handle hardware replacement but software calibration requires Ford IDS.
Estimated cost: $0-650
Transmission Oil Cooler Line Leaks
Occasional · medium severity
Typical onset: 40,000-80,000 mi
Symptoms: Transmission fluid puddles under vehicle, typically passenger side, Transmission fluid level low warning on dash, Harsh shifting or slipping when fluid level drops, Pink or red fluid visible on cooler lines or radiator area
Fix: The 10-speed transmission cooler lines run along the subframe and are prone to chafing or connector seal failure. Requires raising vehicle, draining transmission, replacing lines and fittings, then refilling with Mercon ULV fluid and performing relearn procedure. 2.5-3.5 hours labor plus 6-8 quarts of expensive transmission fluid.
Estimated cost: $600-1,200
PHEV Traction Battery Fault Codes and Charging Issues
Occasional · high severity
Symptoms: Yellow wrench light with 'Service AdvanceTrac' or 'Powertrain malfunction' message, Inability to charge battery, or charging stops prematurely, Reduced electric-only range (below 15 miles when new range was 21), Vehicle defaults to gas-only operation, PHEV functions disabled, High voltage battery cooling fan runs constantly
Fix: Recalls 21S40 and 22S33 address battery cell monitoring and charging control software. Software updates take 1-2 hours at dealer. Physical battery failures (cell imbalance, cooling system faults, or connector issues) require battery pack removal from under rear floor—8-12 hours labor for diagnostics and pack R&R. Individual cell replacement not available; full pack runs $8,000-12,000 parts alone. Most failures occur under 8-year/100k warranty.
Estimated cost: $0-16,000
Front Transmission Mount Failure
Occasional · low severity
Typical onset: 50,000-90,000 mi
Symptoms: Clunk or thud when shifting from Park to Drive or Reverse, Vibration felt through floorboard at idle or light acceleration, Visible engine movement when revving in Park, Driveline shudder during acceleration from stop
Fix: The hydraulic front transmission mount wears from the twin-turbo's torque and AWD weight. Requires supporting powertrain, removing upper mount bolts, and replacing with revised Ford part. Access is tight but doable from top. 2.0-2.5 hours labor. Often done during other underhood work to save redundant teardown.
Estimated cost: $400-700
Seatbelt Pre-Tensioner Warning Light Malfunction
Occasional · low severity
Symptoms: Seatbelt warning light illuminated with 'Seatbelt malfunction' message, Airbag light may accompany seatbelt warning, Warning appears even with seatbelt properly fastened, Second-row seatbelt pretensioner codes most common
Fix: Recalls 21S29 and 22S03 address front seatbelt pretensioner wiring connectors and sensor calibration. Dealer reflash and connector inspection/reseat takes 0.5-1.0 hours, covered under recall. Actual buckle or retractor failure requires seat removal and buckle assembly replacement, 2.0-3.0 hours labor per seat.
Estimated cost: $0-800
Owner tips
Check oil level every 500 miles in the first 60k—early liner failure shows as sudden consumption before catastrophic damage
PHEV models: keep software updated at dealer and verify 12V battery health yearly; low 12V causes cascading electrical faults
Use only Motorcraft Mercon ULV in the 10-speed; other fluids cause valve body issues and void warranty
Subscribe to NHTSA recall alerts for your VIN—Ford has issued 8+ campaigns for 2020 Aviator already
Hard pass unless it's a certified pre-owned with extended powertrain warranty—the cylinder liner failure is a ticking time bomb that can total the vehicle, and out-of-pocket repairs rival the depreciated value.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2020 Lincoln Aviator
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Consequence: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Consequence: Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in May 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
BACK OVER PREVENTION:SOFTWARE · 26V123000
2026-03-03
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: The remedy is currently under development. Interim letters, notifying owners of the safety risk, were mailed April 6, 2026. Additional letters will be sent once the final remedy is available, anticipated second quarter of 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
BACK OVER PREVENTION:SOFTWARE · 25V442000
2025-06-27
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
SEATS:MID/REAR ASSEMBLY · 25V393000
2025-06-13
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.
Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.
STRUCTURE:BODY · 25V407000
2025-06-13
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator vehicles. The rear door window bars and C-pillar trim may have insufficient adhesive bonding, which can allow the trim to detach from the vehicle.
Consequence: Detached trim may cause a road hazard and increase the risk of a crash.
Remedy: Dealers will repair or replace C-pillar appliques and window division bars, free of charge. Owner notification letters were mailed September 29, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S66.
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and Lincoln Corsair vehicles equipped with a Revel Audio System that were repaired incorrectly under recall 22V-953. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An audible warning chime that does not properly alert of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Dealers will update the audio control module software, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C18.
Ford Motor Company (Ford) is recalling certain 2020-2021 Lincoln Aviator vehicles equipped with 3.0L PHEV engines that were repaired incorrectly under recall 23V626. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Dealers will update the Battery Energy Control Module software, free of charge. Owner notification letters were mailed June 26, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S58.
BACK OVER PREVENTION:SOFTWARE · 25V159000
2025-03-14
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 23V-342. The video output may fail, preventing the rearview camera image from displaying.
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S27.
SEAT BELTS · 25V093000
2025-02-14
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Aviator vehicles. The seat belt buckle anchor bolts at one or more seating positions may be improperly secured. Additionally, vehicles may have an improperly secured seat belt retractor anchor bolt and/or seat belt anchor bolt at the second-row center seating position, if equipped.
Consequence: A loose seat belt or seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect seat belt buckle anchor bolts in all seating positions. Additionally, dealers will inspect the seat belt retractor anchor bolt and seat belt anchor bolt at the second-row center seating position, if equipped. If loose anchor bolts are found, the affected seat components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed on June 5, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25S09.
EQUIPMENT:OTHER:LABELS · 24V852000
2024-11-08
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
BACK OVER PREVENTION:DISPLAY FUNCTION · 24V368000
2024-05-24
Ford Motor Company (Ford) is recalling certain 2020-2024 Lincoln Aviator vehicles. The accessory protocol image module (APIM) can be affected by electromagnetic interference with a cell phone in the vehicle, causing the rearview camera image to flicker or become distorted.
Consequence: A flickering or distorted rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Owners are advised not to use their cell phones while reversing until the remedy is completed. Dealers will install shielding on the accessory protocol image module (APIM), free of charge. Owner notification letters were mailed on October 23, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S35.
Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Aviator and Ford Explorer vehicles equipped with 3.0L PHEV engines. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Dealers will perform a Battery Energy Control Module (BECM) diagnostic test and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on April 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S53.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 23V598000
2023-08-25
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator, 2018-2021 Lincoln Navigator, 2022-2023 Ford Transit, and 2021 Ford Bronco vehicles. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, and update the software and wiring as necessary, free of charge. Owner notification letters were mailed November 20, 2023 to Lincoln owners. Ford vehicle owners notification letters were mailed March 4, 2024. Ford remedy parts are anticipated 2nd Quarter 2024. Ford's number for this recall is 23S48.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 23V342000
2023-05-12
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the 360-degree camera, free of charge. Owner notification letters were mailed November 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S23. This recall expands and replaces NHTSA recall number 23V-022. Vehicles previously repaired under 23V-022 will need to have the new remedy performed.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 23V022000
2023-01-23
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the image processing module (IPMB) software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed April 25, 2023. Owner notification letters were mailed February 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S02. This recall expands and replaces NHTSA recall number 21V-735. Vehicles previously repaired under 21V-735 will need to have the new remedy performed.
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and 2020-2022 Lincoln Corsair vehicles equipped with a Revel Audio System. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An audible warning chime that does not properly alert of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Dealers will update the audio control module software, free of charge. Owner notification letters were mailed February 7, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C35.
BACK OVER PREVENTION:SOFTWARE · 21V735000
2021-09-22
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module (IPMB) software, free of charge. Owner notification letters were mailed November 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S44.
Ford Motor Company (Ford) is recalling certain 2020-2021 Lincoln Aviator vehicles equipped with 3.0L gasoline engines. The wire harness may not be secured properly, possibly contacting the air conditioning (A/C) compressor pulley, and resulting in damage to electrical wires, or the A/C compressor drive belt.
Consequence: Damaged electrical wires may short-circuit, increasing the risk of a fire.
Remedy: Dealers will inspect the harness and A/C compressor belt for damage, replacing them as necessary, and install a tie strap to secure the wire harness, free of charge. Owner notification letters were mailed on July 30, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S34.
BACK OVER PREVENTION:DISPLAY FUNCTION · 21V223000
2021-03-30
Ford Motor Company (Ford) is recalling certain 2020-2021 Lincoln Aviator vehicles. The image processing module may be unable to provide video feed to the display, which could result in a loss of the backup camera image. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank or distorted image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the image processing module software with the latest level, free of charge. Owner notification letters were mailed May 21, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C09.
SUSPENSION:REAR · 21V154000
2021-03-10
Ford Motor Company (Ford) is recalling certain 2020 Lincoln Aviator and Ford Explorer vehicles. The rear lower control arm (RLCA) bolts that attach the rear lower control arms to the wheel knuckles may not have been heat-treated, which could cause them to break.
Consequence: Broken RLCA bolts can cause a loss of steering control, and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace both RLCA bolts, free of charge. The recall began on April 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S11.
VISIBILITY:WINDSHIELD WIPER/WASHER · 21V014000
2021-01-15
Ford Motor Company (Ford) is recalling certain 2020 Ford Explorer Police Interceptor Utility and 2020 Lincoln Aviator vehicles. The affected vehicles contain windshield washer fluid that was contaminated with brake fluid. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 104, "Windshield Wiping and Washing Systems."
Consequence: A washer system contaminated with brake fluid can reduce the driver's ability to clear windshield, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will flush out the washer system, replacing the washer bottle neck, washer pump assembly, fluid level sensor and the front and rear wiper blades. Dealers will also inspect and repair the vehicle's paint and exterior components if affected, free of charge. The recall began March 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C01.
ENGINE · 20V788000
2020-12-17
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Lincoln Aviator vehicles. The right hand motor mount fasteners may have been incorrectly tightened, and may loosen over time.
Consequence: With a loose motor mount, motor vibration may cause the axle to disconnect from the engine and could result in loss of power, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will remove and replace the right hand motor mount fasteners, free of charge. The recall began February 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S72.
POWER TRAIN:DRIVELINE:DRIVESHAFT · 20V693000
2020-11-10
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles equipped with a 2.0L or 3.3L engine and a 10 Speed Automatic Transmission with the All Wheel Drive package. The drive shaft may fracture along the weld seam.
Consequence: Defective drive shafts may fail and cause a loss of connection between the transfer case and rear axle, possibly resulting in a vehicle rollaway when in Park or a loss of drive. Either condition can increase the risk of a crash. The drive shafts can also deform and separate from the driveline and potentially contact the fuel tank, increasing the risk of fuel leaks and/or fire.
Remedy: Ford will notify owners, and dealers will inspect the drive shaft label inspected and replace it as necessary, free of charge. The recall began December 11, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S65.
AIR BAGS:CRITICAL FASTENERS · 20V497000
2020-08-21
Ford Motor Company (Ford) is recalling certain 2020 Explorer and 2020 Lincoln Aviator vehicles. The side air bag and/or seat back module attachments may not have been properly tightened in the front seat backs.
Consequence: If the side air bag or seat back fasteners were not properly tightened, the side air bag deployment could be affected, increasing the risk of injury during a crash.
Remedy: Ford will notify owners, and dealers will remove front seat back panels from one or both front seats (VIN-specific) and verify that the fasteners have been properly tightened, free of charge. The recall began September 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S48.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS · 19V859000
2019-12-04
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. Over time, the protective sleeve on the vapor fuel line may chafe through the plastic liquid fuel line and cause a fuel leak.
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will install a longer protective sleeve on the liquid fuel line, as necessary, free of charge. Ford issued owners and interim notification on January 29, 2020. Recall began March 23, 2020. A second notice will be sent once parts are available, expected to be late in the first quarter of 2020. A renotification letter was sent on July 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S49.
SEATS:FRONT ASSEMBLY:RECLINER · 19V633000
2019-08-28
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) · 19V575000
2019-08-05
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."
Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.
Building an app?
Free API access to all this data — 50 requests/day, no card required.