The 2014 MKT shares the Ford Flex/Explorer platform and suffers from serious EcoBoost engine failures plus typical Ford transmission cooler issues. The 3.7L naturally-aspirated V6 is far more reliable, but EcoBoost models dominate the used market and bring expensive surprises.
EcoBoost 3.5L Catastrophic Engine Failure (Carbon Buildup + Timing Chain)
Common · high severityTypical onset: 80,000-120,000 mi
Symptoms: Rough idle and misfires on cold starts, Check engine light with multiple misfire codes, Metallic rattling at startup (timing chain stretch), Sudden loss of power or complete engine seizure
Fix: Direct-injection EcoBoost engines suffer severe carbon buildup on intake valves causing misfires, often combined with timing chain/phaser failures. Walnut blasting valves is a temporary fix (3-4 hours labor), but stretched chains require front engine tear-down (12-16 hours). Many engines at this mileage need full rebuilds or replacement short blocks due to piston/bearing damage from debris.
Estimated cost: $8,000-15,000
Internal Transmission Oil Cooler Failure (6F50/6F55 Transmission)
Common · high severityTypical onset: 70,000-110,000 mi
Symptoms: Transmission slipping or harsh shifts, Milky/strawberry-colored transmission fluid, Coolant in transmission pan, Engine overheating or transmission overheating
Fix: The transmission cooler inside the radiator fails, allowing coolant and ATF to mix—destroys transmission internals rapidly. Requires radiator replacement, complete transmission flush or rebuild, and all cooler lines cleaned (8-12 hours for flush/cooler, 18-24 hours if transmission needs rebuild). MUST address immediately when detected.
Estimated cost: $3,500-7,500
PTU (Power Transfer Unit) Seal Leaks and Failure
Common · medium severityTypical onset: 60,000-100,000 mi
Symptoms: Fluid dripping from front-center of vehicle, Whining or grinding noise during acceleration, Clunking when shifting into gear, Burning smell from undercarriage
Fix: AWD models use a PTU that commonly develops seal leaks, and owners often don't notice until it runs dry and grenades. Seal replacement is 3-4 hours, but if ignored, PTU replacement is 6-8 hours. Ford never implemented a dipstick, so regular 30k-mile fluid changes are critical prevention.
Estimated cost: $600-2,800
Water Pump Failure (EcoBoost Models)
Occasional · high severityTypical onset: 60,000-90,000 mi
Symptoms: Coolant leak from front of engine, Overheating at idle or low speeds, Whining or grinding from water pump area, Steam from under hood
Fix: EcoBoost water pumps are internally driven and fail without much warning. Requires significant front-end disassembly and timing cover removal (6-8 hours). Often done preventively during timing chain service. Overheating from failed pump can warp heads or blow gaskets.
Estimated cost: $1,200-2,000
Rear Shock Absorber Mount Corrosion/Failure
Occasional · medium severityTypical onset: 70,000-120,000 mi
Symptoms: Clunking noise over bumps from rear, Sagging rear end or uneven ride height, Visible rust or separation at shock tower, Excessive body roll in turns
Fix: Rear shock towers rust through on salt-belt vehicles, and upper mounts separate from chassis. Requires shock replacement plus welding/plating repair to shock tower if rust is advanced (3-5 hours per side). Ford issued a recall for some model years but not all. Inspect thoroughly during pre-purchase.
Estimated cost: $800-1,800
Door Latch/Actuator Failures (All Doors)
Occasional · low severitySymptoms: Door won't open from inside or outside, Door ajar warning with doors closed, Power locks cycle repeatedly, Child lock engages randomly
Fix: Ford latch actuators fail across this platform generation. Each door latch assembly is 1.5-2 hours to replace due to door panel removal and cable routing. Rear liftgate latch is particularly troublesome and can trap occupants if rear doors fail simultaneously.
Estimated cost: $350-600
Hard pass on EcoBoost models unless under 60k miles with immaculate service records; the 3.7L naturally-aspirated V6 is the only engine worth considering used, and even then, transmission cooler failure is a ticking time bomb.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.