The 2014 MKZ shares the Ford Fusion platform and suffers from catastrophic 2.0L EcoBoost engine failures, transmission cooler leaks, door latch failures, and EPAS steering issues. The hybrid and 3.7L V6 are more reliable, but the turbocharged four-cylinder has earned a reputation for grenading internals.
Symptoms: white smoke from exhaust, rapid coolant loss with no external leaks, misfires and rough idle, coolant in oil (milky dipstick), sudden loss of power
Fix: Internal coolant leak from failed cylinder head or block porosity hydro-locks cylinders and destroys bearings, rings, and sometimes cracks blocks. Requires complete engine replacement or full rebuild with machining. 18-24 labor hours for short block or long block swap.
Estimated cost: $6,500-9,500
Transmission Oil Cooler Line Leak and Bushing Failure
Common · high severity
Typical onset: 70,000-110,000 mi
Symptoms: transmission fluid puddles under vehicle, burnt transmission fluid smell, slipping or harsh shifts, transmission overheating warnings, loss of all gears if catastrophic
Fix: Plastic cooler line fittings at the radiator crack or the internal cooler itself fails, dumping ATF. If coolant cross-contaminates into transmission, complete flush and often valve body or full transmission replacement needed. Line repair alone: 2-3 hours. Transmission replacement if contaminated: 12-16 hours.
Symptoms: door will not latch closed, door ajar warning with door closed, door pops open while driving, unable to open door from inside or outside
Fix: Pawl spring and latch mechanism fail internally due to poor design. Multiple recalls issued but not all VINs covered. Each latch replacement: 1.5-2 hours per door. Ford updated part numbers available.
Estimated cost: $250-400 per door
Electric Power Steering (EPAS) Loss of Assist
Occasional · high severity
Typical onset: 50,000-90,000 mi
Symptoms: steering assist lost warning, heavy steering effort suddenly, intermittent loss of power steering, warning light and message on dash
Fix: Steering column control module or torque sensor failure. Recalls issued for some VINs but many fall outside coverage. Steering column assembly replacement required in most cases. 3-4 labor hours.
Estimated cost: $1,200-1,800
Water Pump Failure (2.0L EcoBoost and 3.7L V6)
Occasional · high severity
Typical onset: 60,000-100,000 mi
Symptoms: coolant leak from front of engine, squealing noise from accessory belt area, overheating, coolant puddle under vehicle
Fix: Internal water pump seals fail and leak externally or into the engine block on EcoBoost. On 3.7L V6, pulley bearing fails. EcoBoost requires timing cover removal and timing component inspection/replacement. 5-7 hours for EcoBoost, 3-4 hours for V6.
PTU (Power Transfer Unit) Fluid Leak and Failure (AWD Models)
Occasional · medium severity
Typical onset: 80,000-130,000 mi
Symptoms: fluid leak at front of transmission, whining or grinding noise during acceleration, AWD malfunction warning, vibration at highway speeds
Fix: PTU seal leaks or unit runs dry due to lack of maintenance (no dipstick, often neglected). Seal replacement: 3-4 hours. Complete PTU replacement if internals damaged: 6-8 hours. Ford does not list fluid changes in maintenance schedule but should be done every 30k.
Symptoms: intermittent no-start, stalling while driving, loss of power under load, extended cranking before start, fuel pump not priming
Fix: Driver module mounted under vehicle near fuel tank fails due to heat and corrosion. Module replacement: 1.5-2 hours. Sometimes misdiagnosed as fuel pump itself.
Estimated cost: $450-700
Owner tips
Run only premium fuel in EcoBoost engines and keep up with oil changes every 5k miles—sludge accelerates coolant intrusion failures
Service PTU fluid every 30k miles on AWD models even though Ford says it's lifetime—it's not
Check transmission cooler lines at every oil change for seepage; early catch prevents transmission contamination
Inspect door latches during any service—replacement is cheap compared to safety risk
Avoid the 2.0L EcoBoost entirely if buying used; the 3.7L V6 or hybrid are far more durable
Hard pass on 2.0L EcoBoost models—they're ticking time bombs; the 3.7L V6 or hybrid are acceptable if well-maintained and you get a pre-purchase inspection focused on transmission cooler and door latches.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2014 Lincoln MKZ
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS · 23V162000
2023-03-10 · RQ22004
Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.
Consequence: A brake fluid leak will increase brake pedal travel and extend the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed June 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S12.
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES · 22V011000
2022-01-13
Ford Motor Company (Ford) is recalling certain 2014-2015 Fusion, Lincoln MKZ, and 2015 Mustang vehicles originally sold or ever registered, in Texas, Louisiana, Mississippi, Alabama, Florida, Georgia, South Carolina, North Carolina, Virginia and Hawaii. Exposure to certain environmental conditions, such as high temperatures, high humidity, and salt air can cause the brake pedal bumper to corrode and separate from the brake pedal.
Consequence: A separated brake pedal bumper can cause the brake lights to illuminate continuously, causing confusion to other drivers and increasing the risk of a crash. On automatic transmission vehicles, a missing brake pedal bumper can allow the driver to shift the vehicle out of the "PARK" position without depressing the brake, allowing the vehicle to rollaway, increasing the risk of injury.
Remedy: Dealers will replace the brake pedal bumpers and clutch pedal bumpers, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed on March 4, 2022. Owner notification letters were mailed on June 13, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S02.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH · 20V331000
2020-06-08 · RQ19005
Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will inspect the latch date codes to confirm if the repair was done correctly, and replace the side door latches if necessary, free of charge. Owners will also have the option to inspect their own vehicle's door latches and enter the date codes into a website to determine if the latches are correct. Owner notification letters were mailed on July 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S30.
EXTERIOR LIGHTING:HEADLIGHTS · 20E025000
2020-04-24
Ford Motor Company (Ford) is recalling certain Replacement Headlamps, part number DP5Z-13008-T and DP5Z-13008-V, sold for use with 2013-2016 Lincoln MKZ vehicles. The headlamps may have an improper beam pattern and incorrect horizontal adjustment, the side markers may not illuminate and DOT markings may be missing. As such, these headlamps fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: The incorrect headlamps may reduce the driver's visibility or make the vehicle less visible, increasing the risk of a crash.
Remedy: Ford will notify vehicle manufacturers, and dealers will inspect the headlamps, and replace the headlamps, as necessary, free of charge. Additionally, Ford will instruct dealers to return all improper headlamps and not to install them on any vehicles. The recall began June 3, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C10.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH · 20V177000
2020-03-23 · RQ19005
Ford Motor Company (Ford) is recalling certain 2014-2015 Fiesta, 2014-2016 Fusion and Lincoln MKZ vehicles sold, or ever registered in Alabama, Arkansas, Arizona, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, New Mexico, Nevada, Oklahoma, Oregon, South Carolina, Texas, Utah, Washington, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and Ford or Lincoln dealers will replace the side door latches, free of charge. The recall began September 21, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S15.
STEERING:ELECTRIC POWER ASSIST SYSTEM · 19V632000
2019-08-29
Ford Motor Company (Ford) is recalling certain 2013-2016 Ford Fusion and Lincoln MKZ, 2015-2016 Ford Edge, and 2016 Lincoln MKX vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. Road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.
Consequence: If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist, requiring a greater steering effort, especially at lower speeds, and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the steering gear motor bolts and apply a wax sealer. If any of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began October 18, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S26.
STEERING: STEERING WHEEL/HANDLE BAR · 18V167000
2018-03-12 · PE17007
Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.
Consequence: A steering wheel detachment can cause a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the steering wheel bolt with a longer bolt, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S08.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH · 17V210000
2017-03-27
Ford Motor Company (Ford) is recalling certain 2014 Ford Fiesta, 2013-2014 Ford Fusion and 2013-2014 Lincoln MKZ vehicles. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will replace all four door latches, free of charge. The recall began May 1, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S16.
SEAT BELTS:FRONT · 16V875000
2016-12-05
Ford Motor Company (Ford) is recalling certain model year 2013-2016 Ford Fusion vehicles manufactured November 2, 2012, to July 31, 2014, and 2013-2015 Lincoln MKZ vehicles manufactured November 14, 2012, to July 31, 2014. In the event of a crash, heat from the deployment of a seat belt pretensioner may cause a front seat belt anchor cable to fail.
Consequence: If the driver or front passenger seatbelt cables cannot properly restrain the front seat occupants, they would be at an increased risk of injury.
Remedy: Ford will notify owners, and dealers will apply a protective coating to the seat belt cable, free of charge. The recall began May 16, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S42.
STEERING:ELECTRIC POWER ASSIST SYSTEM · 15V250000
2015-04-28
Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Fusion and Lincoln MKZ vehicles manufactured February 3, 2012, to March 20, 2015, and 2015 Ford Edge vehicles manufactured February 26, 2015, to February 28, 2015, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, snow or water containing road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.
Consequence: If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist. Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will apply sealer and replace the steering gear motor bolts as required. If one or more of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began on June 24, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S14.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH · 15V246000
2015-04-24 · EA15002
Ford Motor Company (Ford) notified the agency on April 23, 2015, that they are recalling certain model year 2013-2014 Ford Fusion and Lincoln MKZ vehicles manufactured July 1, 2012, to May 31, 2013, and 2012-2014 Fiesta vehicles manufactured February 1, 2012, to May 31, 2013. On April 30, 2015, Ford expanded the recall to cover an additional 119,567 vehicles, including certain model year 2011 Ford Fiestas manufactured from November 11, 2009, to May 31, 2013 and certain model year 2013 Ford Fusion and Lincoln MKZ vehicles manufactured from February 1, 2012, to June 30, 2012. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will replace all four door latches with an improved part, free of charge. Interim notifications were mailed to owners on June 5, 2015. The recall began on December 18, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S16.
AIR BAGS · 14V597000
2014-09-26
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Ford C-Max vehicles manufactured January 19, 2012, to November 21, 2013; Ford Fusion vehicles manufactured February 3, 2012, to August 24, 2013; Ford Escape vehicles manufactured October 5, 2011, to November 1, 2013; and Lincoln MKZ vehicles manufactured April 25, 2012, to September 30, 2013. The coating on portions of the Restraint Control Module (RCM) may crack, and when exposed to humidity, circuits on the printed circuit board may short.
Consequence: The short circuits could cause the frontal air bags, side curtain air bags and the seat belt pretensioners to not function as intended when needed, increasing the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the RCM, free of charge. Parts are not currently available. The recall began on May 26,2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S21.
SEATS:FRONT ASSEMBLY:RECLINER · 14V164000
2014-04-02
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Ford Fusion and Lincoln MKZ vehicles manufactured August 15, 2012, through September 10, 2013, 2013-2014 Ford Escape vehicles manufactured June 5, 2012, through August 12, 2013, and 2013-2014 Ford C-Max vehicles manufactured from July 23, 2012, through May 28, 2013. The driver and passenger seatback assemblies may have been produced with sub-standard weld joints used to attach the seat back recliner mechanism to the seat frame. The affected seat backs may have insufficient strength to meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence: The back of the subject seats may become loose or lean while driving and potentially increase the risk of injury in certain crashes.
Remedy: Ford will notify owners, and dealers will replace the seatback, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14C03.
POWER TRAIN:AUTOMATIC TRANSMISSION · 13V594000
2013-11-25
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Lincoln MKZ Hybrid vehicles manufactured April 26, 2012, through September 24, 2013. Due to a manufacturing error, the transmission range sensor may not function properly allowing the affected vehicles to be shifted out of the Park position without first applying the brake pedal. Thus, these vehicles fail to conform with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 114, "Theft Protection."
Consequence: Without requiring the brake to be pressed, the vehicle may be unintentionally shifted out of Park, allowing it to roll which may result in a crash.
Remedy: Ford will notify owners, and dealers will update the Powertrain Control Module (PCM) with new software, free of charge. The recall began on January 2014. Customers may contact Ford at 1-866-436-7332. Ford's number for this recall is 13C09.
Building an app?
Free API access to all this data — 50 requests/day, no card required.