The 2022 Model 3 is Tesla's most mature platform, but early-build quality issues persist alongside drive unit failures that can strike suddenly. Software recall frequency is high, though OTA fixes are free—hardware problems like failed inverters and drive motors are the real cost concern.
Rear Drive Unit Failure (RWD and AWD)
Occasional · high severity
Typical onset: 40,000-80,000 mi
Symptoms: Whining or grinding noise from rear axle during acceleration, Reduced power warning on dash, Vehicle enters limp mode or refuses to drive, Metal shavings in drive unit fluid during service
Fix: Complete rear drive unit replacement required—Tesla rarely rebuilds these in-field. 6-8 hours labor if parts are in stock. Inverter coolant flush recommended during replacement. Extended warranty often covers this if under 8yr/100k powertrain.
Estimated cost: $5,000-8,000
High Voltage Battery Coolant Leak
Occasional · high severity
Typical onset: 50,000-90,000 mi
Symptoms: Green coolant puddle under vehicle center, Battery heating/cooling malfunction warning, Reduced charging speed or range loss, Supercharging disabled or limited to 50kW
Fix: Usually failed quick-disconnect fittings or corroded cooling lines at battery pack connections. Requires lifting vehicle, dropping skid plate, accessing connections. 4-6 hours labor. Occasionally requires full pack R&R if internal module leak (12-16 hours). Diagnostics critical—don't throw parts at this.
Estimated cost: $1,200-3,500
Inverter Failure (Front or Rear)
Rare · high severity
Symptoms: Complete loss of propulsion without warning, High-pitched squealing from motor compartment, Inverter overheating warnings, Vehicle will not shift into Drive
Fix: Inverter replacement—typically rear on RWD, either unit on AWD. 5-7 hours labor including coolant service. Tesla part only, no aftermarket. This is a tow-in failure. Some early 2022 builds had faulty capacitors—check for TSBs.
Estimated cost: $4,500-7,000
AC Evaporator Core Failure
Common · medium severity
Typical onset: 30,000-70,000 mi
Symptoms: AC blows warm intermittently or constantly, Musty smell from vents, Refrigerant leak detected at evaporator, Condensation dripping into cabin footwell
Fix: Dash removal required—this is the big one. 12-16 hours labor because entire dash assembly comes out for evaporator access. Common failure point on 2021-2022 builds. Use OEM evaporator—aftermarket units fail within a year. Flush and recharge AC system during repair.
Estimated cost: $3,000-5,500
Front Suspension Lower Control Arm Bushings
Common · low severity
Typical onset: 50,000-80,000 mi
Symptoms: Clunking over bumps from front end, Steering wander or vague on-center feel, Uneven front tire wear (inner edge), Failed state inspection due to excessive play
Fix: Replace both front lower control arms as assembly—bushings not serviceable separately on Model 3. Alignment mandatory after replacement. 3-4 hours labor including alignment. Check ball joints at same time—they often go together on higher-mileage cars.
Estimated cost: $800-1,400
12V Battery Failure
Occasional · medium severity
Symptoms: Vehicle will not unlock or 'wake up', Repeated low 12V battery warnings in app, Accessories work but vehicle won't initialize drive system, Completely dead—no door handles, no screen
Fix: 12V lithium-ion battery (not lead-acid like older Teslas) typically lasts 3-5 years but can fail suddenly. 0.5-1 hour labor—it's under the front trunk liner. Mobile service can do this. Keep a jump box in the car—you'll need it to pop the manual release if battery dies away from home.
Estimated cost: $200-400
Charge Port Latch Failure
Occasional · low severity
Symptoms: Charge cable won't release after charging session, Port door won't open or close properly, Charging interrupted randomly, Manual release required to remove cable
Fix: Motorized latch mechanism in charge port assembly fails—moisture intrusion common. 1-2 hours labor, port assembly replacement. Not covered under warranty if damage from forced removal. Temporary fix: manual release cable in trunk, but replace the assembly—it will fail again.
Estimated cost: $400-700
Owner tips
Change drive unit fluid every 50k mi despite Tesla saying 'lifetime'—$200 service that prevents $7k drive unit replacement
Flush inverter coolant every 4 years—overheating kills expensive components
Run battery down to 10% and back to 90% monthly to keep calibration accurate—prevents phantom range loss
Update software immediately when prompted—many recalls are OTA and prevent hardware failures
Inspect HV battery coolant lines and fittings annually—green stains are early warning signs
Buy a 2022 if you can verify drive unit health and AC function—budget $2k/year for out-of-warranty surprises, but daily reliability is excellent once these issues are addressed.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2022 Tesla Model 3
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS · 24V935000
2024-12-17
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence: Driving with improperly inflated tires increases the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
LATCHES/LOCKS/LINKAGES:HOOD:LATCH · 24V554000
2024-07-24
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
Consequence: An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.
Remedy: Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Consequence: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Consequence: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
STEERING:AUTOMATED/ADAPTIVE STEERING · 23V085000
2023-02-15 · EA22002
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
Consequence: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
SEAT BELTS:REAR/OTHER:ANCHORAGE · 22V798000
2022-10-21
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat
belt anchor may have been incorrectly reassembled during vehicle service.
Consequence: An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Remedy: Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS · 22V702000
2022-09-19
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
Consequence: A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Remedy: Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
BACK OVER PREVENTION:DISPLAY FUNCTION · 22V296000
2022-05-03
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S, Model X, and 2022 Model 3 and Model Y vehicles operating certain firmware releases. The infotainment central processing unit (CPU) may overheat during the preparation or process of fast-charging, causing the CPU to lag or restart.
Consequence: A lagging or restarting CPU may prevent the center screen from displaying the rearview camera image, gear selection, windshield visibility control settings, and warning lights, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will improve CPU temperature management, free of charge. Owner notification letters were mailed July 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-009.
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence: The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
ELECTRICAL SYSTEM:SOFTWARE · 22V235000
2022-04-12
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
ELECTRICAL SYSTEM:SOFTWARE · 22V063000
2022-02-04 · DP22005
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
ELECTRICAL SYSTEM:SOFTWARE · 22V050000
2022-02-02
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence: Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.
ELECTRICAL SYSTEM:SOFTWARE · 22V045000
2022-02-01
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Consequence: Failing to stop at a stop sign can increase the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Building an app?
Free API access to all this data — 50 requests/day, no card required.