The 2018 Model 3 is Tesla's mass-market entry with solid drivetrain fundamentals but early production quality issues. Main concerns center on drive unit failures, HVAC component longevity, and 12V battery neglect causing cascading electrical gremlins.
Rear Drive Unit Failure (Milling/Whining Noise)
Occasional · high severity
Typical onset: 60,000-100,000 mi
Symptoms: High-pitched whine or grinding from rear axle during acceleration, Vibration through chassis at highway speeds, Error messages: 'Drivetrain power reduced' or 'Schedule service', Metallic debris in drive unit fluid during service
Fix: Full rear drive unit replacement under warranty extension for many 2018s; out-of-warranty requires complete unit swap (Tesla reman or third-party rebuild). 4-6 hours labor for R&R plus fluid refill. Independent shops struggle with parts access—Tesla service center often required.
Estimated cost: $3,500-7,000
HVAC Evaporator Coil Clogging/Failure
Common · medium severity
Typical onset: 40,000-80,000 mi
Symptoms: Weak or no cabin cooling despite compressor running, Musty odor from vents, Condensate water pooling under passenger footwell, Climate control displays normal temps but cabin stays hot
Fix: Evaporator replacement requires full dash removal—extremely labor-intensive on Model 3. 10-14 hours at independent shops familiar with Tesla architecture. OEM part required; aftermarket options unreliable. Some techs attempt flush first (1-2 hours) but success rate under 30%.
Estimated cost: $2,800-4,500
12V Lead-Acid Battery Premature Failure
Common · high severity
Symptoms: Vehicle won't unlock or wake from sleep mode, Touchscreen black or stuck on Tesla logo, Frunk won't open electronically (manual release required), Error: 'Low 12V battery voltage' before total failure, Complete loss of access despite full high-voltage battery charge
Fix: 12V battery hidden under front trunk floor; many 2018s fail at 2-4 years regardless of mileage due to undersized capacity and deep discharge cycles. Replacement straightforward: 0.5-1 hour including access panel removal. Upgrade to lithium 12V (Ohmmu) recommended for longevity. Critical: this battery powers ALL vehicle computers—failure bricks the car.
Estimated cost: $300-600
Upper Control Arm Ball Joint Clunking
Occasional · medium severity
Typical onset: 50,000-90,000 mi
Symptoms: Clunking from front suspension over bumps or turning, Increased tire wear on inner edge, Steering feels loose or vague at highway speeds, Visible play when checking ball joint with pry bar
Fix: Tesla uses non-replaceable ball joints pressed into upper control arms—entire arm must be replaced per side. 2-3 hours labor per side including alignment. Tesla OEM or aftermarket (Moog, Mevotech) available. Some shops report premature wear due to vehicle weight and torque stresses. Always do alignment after.
Estimated cost: $800-1,400
Touchscreen MCU1 Yellowing/Unresponsiveness
Common · medium severity
Symptoms: Yellow border forming around screen edges (glue degradation), Laggy or unresponsive touchscreen inputs, Backup camera slow to display or frozen, Infotainment reboots spontaneously, eMMC memory failure warning (older software)
Fix: 2018 Model 3s with MCU1 (Intel Atom) prone to eMMC flash memory wear-out. Tesla offers MCU2 upgrade ($1,500 parts+labor at service center) with faster processor and improved longevity. Independent repair involves eMMC chip replacement (3-4 hours, specialized soldering) but voids any remaining warranty. MCU2 upgrade strongly recommended over patch repairs.
Estimated cost: $1,500-2,200
Charge Port Door Actuator Failure
Occasional · low severity
Typical onset: 70,000-120,000 mi
Symptoms: Charge port door won't open when pressed or via app, Door opens partially then sticks, Manual release cable required to access port, Grinding noise from actuator motor behind driver-side taillight
Fix: Actuator motor or linkage wears from repeated cycling. Access requires partial rear bumper removal and taillight assembly out. 1.5-2 hours labor. Aftermarket actuators available but fitment inconsistent—OEM Tesla part recommended. Some owners report improving longevity by lubricating pivot points yearly.
Estimated cost: $400-700
Owner tips
Check 12V battery voltage monthly via touchscreen (under software/power menu); replace proactively at 3 years to avoid being stranded
Change rear drive unit fluid every 50,000 miles and inspect for metallic debris—early warning for bearing wear
Use Tesla's mobile app to monitor for software update recalls; many 2018 issues resolved via OTA patches
Budget for MCU2 upgrade if buying with MCU1—consider it deferred maintenance, not optional
Inspect upper control arm ball joints at every tire rotation; early replacement avoids alignment damage
Solid daily driver if the 12V battery and drive unit check out clean—budget $2-3K for deferred MCU/HVAC work on higher-mileage examples.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2018 Tesla Model 3
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS · 24V935000
2024-12-17
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence: Driving with improperly inflated tires increases the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Consequence: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Consequence: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
SUSPENSION:FRONT · 23V235000
2023-03-31
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
Consequence: A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
STEERING:AUTOMATED/ADAPTIVE STEERING · 23V085000
2023-02-15 · EA22002
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
Consequence: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
SEAT BELTS:REAR/OTHER:ANCHORAGE · 22V798000
2022-10-21
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat
belt anchor may have been incorrectly reassembled during vehicle service.
Consequence: An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Remedy: Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS · 22V702000
2022-09-19
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
Consequence: A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Remedy: Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence: The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
ELECTRICAL SYSTEM:SOFTWARE · 22V235000
2022-04-12
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
BACK OVER PREVENTION:DISPLAY FUNCTION · 22V169000
2022-03-18
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
ELECTRICAL SYSTEM:SOFTWARE · 22V063000
2022-02-04 · DP22005
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
ELECTRICAL SYSTEM:SOFTWARE · 22V045000
2022-02-01
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Consequence: Failing to stop at a stop sign can increase the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
Consequence: A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Remedy: Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA · 21V846000
2021-10-29
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Consequence: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
SEAT BELTS · 21V389000
2021-05-25
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
Consequence: An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Remedy: Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Building an app?
Free API access to all this data — 50 requests/day, no card required.