The 2008 Pilot with the J35 V6 is generally reliable but has two standout killers: automatic transmission failure from clogged coolers and catastrophic engine oil consumption leading to cylinder/bearing damage. These aren't minor fixes—they're drivetrain replacements.
Automatic Transmission Failure from Cooler Contamination
Common · high severity
Typical onset: 80,000-150,000 mi
Symptoms: Harsh or delayed shifts, especially 2nd to 3rd gear, Transmission slipping or shuddering under load, Metal debris in fluid during service, Overheating warnings or burnt ATF smell
Fix: The internal transmission cooler deteriorates and contaminates the entire system with aluminum particles. Requires transmission rebuild or replacement, external cooler install, and complete system flush. 12-16 labor hours for removal, rebuild, and reinstall.
Estimated cost: $3,500-5,500
Catastrophic Oil Consumption and Piston Ring Failure
Occasional · high severity
Typical onset: 100,000-180,000 mi
Symptoms: Burning 1+ quart every 1,000 miles, Blue smoke on startup or acceleration, Engine knock or rod bearing noise if oil runs low, Cylinder misfires on startup, clears when warm
Fix: Piston rings fail to seal due to carbon buildup and weak ring tension design. Light cases can limp with frequent top-offs, but proper fix requires engine teardown with piston/ring replacement or short block. 18-24 hours labor for complete rebuild.
Estimated cost: $4,500-7,000
Takata Airbag Inflator Rupture Risk
Common · high severity
Symptoms: Recall notices for driver and passenger airbag inflators, No visible symptoms until deployment failure, Metal shrapnel injury risk in frontal crashes
Fix: Multiple NHTSA recalls for front airbag inflators that can explode and send metal fragments into cabin. Dealer-only repair, free under recall. Verify completion before purchase—many 2008s still unrepaired. 1-2 hours per side.
Estimated cost: $0 (recall)
VCM (Variable Cylinder Management) Fouling and Misfire
Occasional · medium severity
Typical onset: 70,000-140,000 mi
Symptoms: Cylinder 1, 4, or 6 misfire codes, Rough idle when engine drops to 3-cylinder mode, Spark plug fouling on deactivated cylinders, Check engine light with VCM-related codes
Fix: VCM system causes uneven wear and carbon buildup on cylinders that deactivate. Requires VCM solenoid cleaning/replacement, spark plugs, and sometimes injector service. Many owners install VCM disable devices. 3-5 hours.
Estimated cost: $600-1,200
Front and Rear Engine/Transmission Mounts Collapse
Common · low severity
Typical onset: 90,000-150,000 mi
Symptoms: Clunk when shifting from park to drive/reverse, Vibration at idle, especially with AC on, Excessive engine movement visible under hood during acceleration
Fix: Hydraulic mounts fail and leak fluid. Front and rear mounts most problematic. Straightforward replacement. 2-3 hours for both front and rear.
Estimated cost: $400-700
Power Steering Pump Whine and Leak
Occasional · medium severity
Typical onset: 100,000-160,000 mi
Symptoms: High-pitched whine at startup or when turning, Fluid leak from pump or high-pressure line, Heavy steering at low speed when fluid low
Fix: Pump seals fail or internal vanes wear. Replacement pump and fresh fluid. Sometimes pressure line needs replacement too. 2-3 hours.
Estimated cost: $500-900
Owner tips
Change ATF every 30,000 miles with Honda DW-1 fluid only—never 'lifetime' fluid claims
Monitor oil consumption religiously starting at 80k; top off frequently if burning starts
Install an external transmission cooler preemptively if towing or in hot climates
Consider VCM disable (VCMuzzler) to prevent cylinder deactivation wear if keeping long-term
Verify Takata airbag recalls completed before purchase—check NHTSA by VIN
Solid platform if transmission and airbags are sorted, but oil consumption risk makes high-mileage examples a gamble—budget $5k-7k for catastrophic drivetrain failure.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2008 Honda Pilot
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
Dorman Products, Inc. (Dorman) is recalling certain Accelerator Pedal Assemblies part numbers 699-114 and 825-5029-1, sold as replacement parts for 2003-2006 Acura MDX, 2004-2008 Acura TL and TSX, 2003-2007 Honda Accord, 2005-2006 Honda CR-V, 2007-2011 Honda Element, 2005-2008 Honda Pilot and 2006-2014 Honda Ridgeline vehicles. The rotating portion of the accelerator pedal assembly may bind. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 124, "Accelerator Control Systems."
Consequence: If the accelerator pedal binds, the engine may not quickly return to idle after the pedal is no longer pressed, increasing the risk of a crash.
Remedy: Dorman will notify owners, and qualified service facilities will replace the affected accelerator pedal assemblies, free of charge. The recall began December 9, 2019. Owners may contact Dorman customer service at 1-800-523-2492, using option 5. Dorman's number for this recall is AS1019XXXX.
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE · 19V499000
2019-06-27 · EA15001
Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles.
These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are Q5A and Y58.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 19V501000
2019-06-27 · EA15001
Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles.
The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the passenger frontal airbag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are E5D and X5C.
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE · 19V182000
2019-03-06 · EA15001
Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.
Consequence: An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the driver's air bag inflator with an alternate inflator, free of charge. The recall began April 10, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is O41. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is U40.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V268000
2018-04-26
Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.
Consequence: An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 17V029000
2017-01-10 · EA15001
Honda (American Honda Motor Co.) is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2011 Honda Element vehicles, 2005-2012 Acura RL vehicles, 2006-2012 Honda Ridgeline vehicles, 2007-2008 Honda Fit vehicles and 2005-2008 Honda Pilot vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A."
Additionally, if not included in "Zone A" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2009 Acura RL and Honda Element vehicles, 2007-2008 Honda Fit vehicles, 2005-2008 Honda Pilot vehicles and 2006-2009 Honda Ridgeline vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B."
Additionally, if not included in "Zone A" or "Zone B" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2008 Acura RL, Honda Element and Honda Pilot vehicles, 2007-2008 Honda Fit vehicles and 2006-2008 Honda Ridgeline vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall bagan March 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KD9 and KE0.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 16V344000
2016-05-23 · EA15001
Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A."
Additionally, unless included in "Zone A" above, Honda is recalling certain model year 2003-2006 Acura MDX, 2005-2008 Acura RL, 2005-2006 Honda CR-V, 2003-2008 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2008 Ridgeline vehicles originally sold, or that have ever been registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B."
Lastly, unless included in "Zone A" or "Zone B" above, Honda is recalling model year 2002-2004 Odyssey and model year 2003-2004 Acura MDX, Honda Element, and Honda Pilot vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began June 27, 2016. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KA0, KA1, KA2, and KA3.
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE · 15V320000
2015-05-28 · EA15001
Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began on July 1, 2015. Owners may contact Honda customer service at 1-888-234-2138. Owners may contact Acura customer service at 1-800-382-2238, select option 4. Note: Vehicles that have had their driver frontal air bag replaced previously as part of a recall remedy prior to September 12, 2014 need to have their air bag replaced under this recall as well. Vehicles that, on or after September 12, 2014, received a remedy for a prior driver frontal air bag inflator recall already received an inflator of a different design, and therefore are not included in this recall and do not require additional servicing. Note: This recall fully supersedes recalls 08V-593, 09V-259, 10V-041, 11V-260, 14V-351 and 15V-153. Honda's numbers for this recall are JQ9, JR0, JR1, JR2, JR3, JR4, JR5, JR6, JR7, and JR8.
EQUIPMENT:MECHANICAL:CARRIER/RACK · 08E013000
2008-02-05
HONDA IS RECALLING 2,032 HITCH STYLE BIKE RACKS SOLD AS AFTERMARKET FOR USE ON MY 2003-2007 AND SOME MY 2008 HONDA PILOT, RIDGELINE, AND ACURA MDX VEHICLES. A PINCH BOLT EXISTS BETWEEN THE BIKE ARM BRACKET AND THE UPRIGHT ASSEMBLY OF THE "HITCH" STYLE BICYCLE RACK.
Consequence: WHEN MOVING THE BIKE ARM BRACKET TO ITS DOWN POSITION, THIS PINCH BOLT HAS THE POTENTIAL OF CAUSING SEVERE LACERATION OR AMPUTATION TO THE USER'S FINGERTIPS OR HAND.
Remedy: OWNERS SHOULD CONTACT THULE AT 800-THULE91 (800-848-5391) TO OBTAIN A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS OR OWNERS MAY CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238 FOR FURTHER INFORMATION.
Building an app?
Free API access to all this data — 50 requests/day, no card required.