The 2012 Versa with the 1.6L HR16DE is a bare-bones economy car that suffers from two critical flaws: catastrophic CVT transmission failures and a shocking tendency for complete engine destruction due to piston ring wear and oil consumption, often before 100,000 miles.
CVT Transmission Catastrophic Failure
Common · high severity
Typical onset: 60,000-120,000 mi
Symptoms: Shuddering or jerking during acceleration, especially 15-40 mph, Whining or grinding noise from transmission, Loss of power, hesitation, or slipping between gears, Complete failure to move forward or reverse
Fix: Nissan's Jatco CVT-7 is a known grenade. Fluid changes every 30k help but rarely prevent failure. Replacement with remanufactured unit runs 8-12 labor hours. Used units are risky—most have same defect. No cost-effective repair exists once internal damage occurs.
Estimated cost: $3,000-4,500
HR16DE Engine Oil Consumption and Piston Ring Failure
Common · high severity
Typical onset: 70,000-110,000 mi
Symptoms: Burning 1+ quart of oil every 1,000 miles, Blue smoke from exhaust on startup or acceleration, Check engine light with misfire codes (P0300-P0304), Loss of compression, rough idle, eventual engine seizure
Fix: Piston rings carbon up and lose tension due to design flaw in ring pack and oil return holes. Requires complete engine teardown: new pistons, rings, rod bearings, honing, head gasket—essentially a rebuild. Many shops quote short-block replacement instead at 18-25 labor hours. If caught early (just oil consumption), some have success with piston ring replacement only (12-16 hours), but failure rate is high.
Estimated cost: $3,500-6,000
Transmission Oil Cooler Line Failure
Occasional · medium severity
Typical onset: 80,000-140,000 mi
Symptoms: Transmission fluid puddle under vehicle (pink/red), Transmission overheating warning, Harsh shifting or slipping after fluid loss, Metal lines rusted through near radiator connection
Fix: Steel cooler lines rust through at bend points or crimp fittings. Replacement requires dropping splash shields and sometimes draining radiator if integrated cooler. 2-3 labor hours plus CVT fluid refill and burping procedure. If caught before fluid loss causes CVT damage, relatively straightforward.
Estimated cost: $400-700
Front Coil Spring Fracture (Recall but Still Fails)
Occasional · high severity
Typical onset: 60,000-100,000 mi
Symptoms: Loud snap or pop noise from front suspension, Vehicle sitting lower on one corner, Tire contacting wheel well or irregular wear, Loss of handling control, especially in turns
Fix: Multiple recalls issued but springs continue to fracture due to corrosion and metallurgy issues. Broken spring can puncture tire or cause loss of control. Replacement requires spring compressor and full strut removal—3-4 hours per side. Some techs replace both sides preventively. Aftermarket units from quality suppliers (KYB, Moog) seem more durable than OEM.
Estimated cost: $350-600
Takata Airbag Inflator Recall (Driver and Passenger)
Common · high severity
Symptoms: SRS airbag warning light (if inflator has begun degradation), No symptoms until deployment—then metal shrapnel risk, Recall notices mailed to registered owners
Fix: Five separate Takata recalls affect this year. Inflators degrade over time in humid climates and can explode violently on deployment, sending metal fragments into cabin. Replacement is FREE at any Nissan dealer—takes 1-2 hours. Check NHTSA database with VIN before purchasing. Unrepaired units are safety hazards and may be illegal to sell in some states.
Estimated cost: $0 (dealer recall repair)
Engine Mount Failure (Especially Transmission Mount)
Common · low severity
Typical onset: 70,000-120,000 mi
Symptoms: Excessive engine rocking during acceleration or braking, Clunking when shifting from Park to Drive, Vibration felt through cabin at idle, Transmission shifter feels loose or imprecise
Fix: Hydraulic transmission mount (right side) fails most often—oil leaks out and mount collapses. Front and rear engine mounts also wear. Trans mount replacement is 1.5-2 hours, requires supporting powertrain. Often recommend replacing all three together since access is similar—adds another 1-2 hours. Helps reduce stress on CVT.
Estimated cost: $250-600
Owner tips
Change CVT fluid every 30,000 miles with Nissan NS-2 or NS-3 spec fluid—extends transmission life from 'when' to 'maybe not'
Check oil level every fillup—these engines drink oil and will seize without warning once consumption starts
Address Takata airbag recalls immediately—this is not optional
Inspect front coil springs annually for rust or cracks, especially in salt states
Budget $3,000+ in reserves if buying used—transmission or engine failure is more likely than not before 150k miles
Only buy if free or under $2,000—the CVT and engine are ticking time bombs that often cost more to fix than the car is worth.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2012 Nissan Versa
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE · 22E066000
2022-08-09
Nissan North America, Inc. (Nissan) is recalling certain air bag inflator replacement service parts that may have been installed as part of a theft or collision repair. The parts include certain passenger-side air bag inflators designed to fit Infiniti 2002-2003 QX4, 2006-2010 M35 and M45; Nissan 2001-2003 Maxima, 2002-2006 Sentra, and both driver and passenger-side inflators designed to fit 2007-2012 Versa Sedan and Versa Hatchback vehicles. Please see Nissan's recall report for the specific part numbers. These replacement inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Dealers will inspect and replace the inflators as necessary, free of charge. Owner notification letters are expected to be mailed September 14, 2022. Owners may contact Nissan's customer service at 1-800-867-7669.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V401000
2018-06-15 · EA15001
Nissan North America, Inc. (Nissan) is recalling certain 2011 Nissan Versa sedan vehicles and 2011-2012 Nissan Versa hatchback vehicles ever registered in the states of Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia. Nissan is also recalling 2010-2011 Nissan Versa sedan vehicles and 2010-2012 Nissan Versa hatchback vehicles ever registered in the states of ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming.
In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 5, 2018. Owners may contact Nissan customer service at 1-800-867-7669.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V044000
2018-01-10 · EA15001
Nissan North America, Inc. (Nissan) is recalling certain 2009-2012 Versa Hatchback, and 2009-2011 Versa Sedan vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A."
Additionally, Nissan is recalling certain 2009-2010 Versa Hatchback, and Versa Sedan vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B."
Nissan is also recalling certain 2009 Versa Hatchback and Versa Sedan vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.
SUSPENSION:FRONT:SPRINGS:COIL SPRINGS · 17V637000
2017-10-11
Nissan North America, Inc. (Nissan) is recalling certain 2012 Versa Hatchback vehicles that were sold or ever registered in the District of Columbia, Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia and Wisconsin. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.
Consequence: If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.
Remedy: Nissan will notify owners, and dealers will replace both front coil springs, free of charge. The recall began December 6, 2017. Owners may contact Nissan customer service at 1-800-647-7261. This campaign expands recall 15V573.
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE · 17V449000
2017-07-17 · EA15001
Nissan North America, Inc. (Nissan) is recalling certain 2007-2011 Versa Sedan and 2007-2012 Versa Hatchback vehicles. The affected vehicles have a driver frontal air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to moderate absolute humidity, temperatures, and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the subject inflator with a new one manufactured by a different supplier, free of charge. The recall began on March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.
AIR BAGS:SIDE/WINDOW · 17V144000
2017-03-06 · PE16013
Nissan North America, Inc. (Nissan) is recalling certain 2012 Nissan Versa vehicles. Degradation of the side impact sensor connector pins may cause the curtain and seat-mounted air bags to deploy unexpectedly if the door is slammed.
Consequence: If the curtain and seat-mounted air bags inadvertently deploy, it can increase the risk of injury.
Remedy: Nissan will notify owners, and dealers will install a new jumper harness, and replace the side impact satellite sensors, free of charge. The recall began November 28, 2017. Owners may contact Nissan customer service at 1-800-647-7261.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 17V028000
2017-01-10 · EA15001
Nissan North America, Inc. (Nissan) is recalling certain 2012 Nissan Versa hatchbacks originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan) and the U.S. Virgin Islands, or "Zone A".
Additionally, if not included in "Zone A" above, Nissan is recalling certain 2009-2010 Infiniti M35 and M45 and 2009 Nissan Versa sedans and hatchbacks originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B".
Additionally, if not included in "Zone A" or "Zone B" above, Nissan is recalling certain 2005-2008 Infiniti FX35 and FX45, 2006-2010 Infiniti M35 and M45, and 2007-2008 Nissan Versa vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators, free of charge. The recall began on June 8, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Nissan customer service at 1-800-647-7261.
SUSPENSION:FRONT:SPRINGS:COIL SPRINGS · 15V573000
2015-09-14 · PE15019
Nissan (Nissan North America, Inc.) is recalling certain model year 2007-2012 Nissan Versa vehicles manufactured May 8, 2006, to November 12, 2012, that were sold or ever registered in the District of Columbia, Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia and Wisconsin. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.
Consequence: If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.
Remedy: Nissan will notify owners, and dealers will replace both front coil springs, free of charge. The recall began on February 2, 2016. Owners may contact Nissan customer service at 1-800-647-7261.
Nissan North America, Inc. (Nissan) is recalling certain model year 2012-2015 Nissan Versa sedan vehicles manufactured June 9, 2011, to March 11, 2015, and 2014-2015 Nissan Versa Note vehicles manufactured April 23, 2013, to March 11, 2015. The affected vehicles have a center console trim panel that may catch the driver's shoe and delay the transition from the accelerator pedal to the brake pedal.
Consequence: A delay in the application of the brake pedal would lengthen the distance needed to stop the vehicle and increase the risk of a crash.
Remedy: Nissan will notify owners, and dealers will modify the console trim panel, free of charge. The recall began on September 14, 2015. Owners may contact Nissan customer service at 1-800-647-7261.
AIR BAGS:SIDE/WINDOW · 12V055000
2012-02-14
NISSAN IS RECALLING CERTAIN MODEL YEAR 2012 ALTIMA AND VERSA VEHICLES. THESE VEHICLES MAY BE EQUIPPED WITH SIDE CURTAIN AIR BAGS THAT CONTAIN AN INCORRECT PROPELLANT MIXTURE FOR THE INITIATOR COMPONENT USED, RESULTING IN INSUFFICIENT OUTPUT OF COMPRESSED GAS.
Consequence: THE SIDE CURTAIN AIR BAGS MAY NOT DEPLOY, INCREASING THE RISK OF INJURY.
Remedy: NISSAN WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE ONE OR BOTH SIDE CURTAIN AIR BAG MODULES, AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 12, 2012. OWNERS MAY CONTACT NISSAN CUSTOMER SERVICE AT 615-725-1000.
POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR · 12V032000
2012-02-01
NISSAN IS RECALLING CERTAIN MODEL YEAR 2012 VERSA VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION AND MANUFACTURED FROM JUNE 9, 2011, THROUGH JANUARY 13, 2012 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114,THEFT PROTECTION. DUE TO INTERFERENCE BETWEEN THE SHIFTER ROD AND THE SHIFT KNOB, THE VEHICLES MAY BE SHIFTED OUT OF THE PARK POSITION WITHOUT DEPRESSING THE BRAKE PEDAL.
Consequence: THE OPERATOR CAN INADVERTENTLY SHIFT THE VEHICLE INTO GEAR WITHOUT THE BRAKE PEDAL BEING DEPRESSED, INCREASING THE RISK OF A CRASH OR INJURY TO A NEARBY PEDESTRIAN.
Remedy: NISSAN WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE SHIFTER KNOB OR THE SHIFTER ASSEMBLY AS NEEDED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MEARH 5, 2012. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Building an app?
Free API access to all this data — 50 requests/day, no card required.