The 2022 Lincoln Corsair shares the Ford Escape platform and inherits both its strengths and weaknesses. Chief concerns center on transmission cooling issues, 8-speed transmission software glitches, backup camera failures, and PHEV-specific battery cooling problems.
8-Speed Automatic Transmission Oil Cooler Failure
Common · high severity
Typical onset: 20,000-50,000 mi
Symptoms: Transmission overheating warnings on dash, Harsh shifting or delayed engagement after highway driving, Trans fluid leaking from cooler lines at radiator, Limp mode activation in hot weather or under load
Fix: Replace transmission oil cooler and flush system. Ford issued TSB 21-2296 addressing this. 3-4 hours labor plus cooler assembly and fresh fluid. Often covered under powertrain warranty if caught early.
Estimated cost: $800-1,400
Backup Camera System Intermittent Failure
Common · medium severity
Symptoms: Black screen or 'Camera unavailable' message when shifting to reverse, Intermittent operation—works after restart then fails again, Blue screen or pixelated image, Multiple NHTSA recalls (21V-831, 22V-033) address software and hardware failures
Fix: Typically requires camera module replacement and SYNC software update via FDRS. Dealer-level repair due to programming requirements. 1.5-2 hours labor.
Estimated cost: $400-700
Transmission Control Module Software Glitches
Occasional · medium severity
Typical onset: 15,000-60,000 mi
Symptoms: Hard 2-3 or 3-4 upshifts, especially when cold, Transmission 'hunting' between gears at steady cruise, Harsh downshifts to a stop, Check engine light with P0756 (shift solenoid B) or similar codes
Fix: Ford TSB 22-2107 covers TCM reprogramming for shift quality. Sometimes requires valve body replacement if mechanical damage occurred. Programming is 0.5 hours, valve body is 6-8 hours.
Estimated cost: $150-2,800
PHEV Traction Battery Cooling System Defects (2.5L PHEV only)
Occasional · high severity
Symptoms: Reduced EV range or 'Battery system fault' warnings, Battery overheating messages in hot climates, Loss of electric-only mode capability, NHTSA recall 22V-877 covers coolant leaks into battery pack
Fix: Recall repair involves battery pack inspection and possible replacement. If out of recall scope, battery pack replacement is dealer-only and catastrophically expensive. 8-12 hours labor.
Estimated cost: $500-18,000
AC Evaporator and TXV Failures
Occasional · medium severity
Typical onset: 40,000-80,000 mi
Symptoms: Weak or no cold air from vents, Hissing sound behind dash when AC cycles, Moisture accumulation on passenger floor, Refrigerant level drops repeatedly without external leaks
Fix: Evaporator requires full dash removal—labor-intensive job on this platform. 10-14 hours labor plus evaporator, TXV, drier, and refrigerant. Often both TXV and evaporator fail together.
Estimated cost: $1,800-3,200
Subframe Bushing Deterioration and Subframe Corrosion
Occasional · medium severity
Typical onset: 50,000-90,000 mi
Symptoms: Clunking over bumps from front end, Steering feels vague or wandering on highway, Visible tears in front subframe bushings, In salt-belt states, subframe corrosion accelerates bushing wear
Fix: Replace front subframe bushings—requires subframe drop. 4-6 hours labor. In severe corrosion cases, subframe replacement needed (8-10 hours). Common in Northeast/Midwest vehicles.
Estimated cost: $800-3,500
Dashboard Rattles and Trim Separation
Common · low severity
Typical onset: 10,000-40,000 mi
Symptoms: Rattling or buzzing from center stack or passenger side dash, Dashboard seams visibly separating near windshield, Creaking sounds over bumps from instrument panel, Headliner sagging near rear hatch (less common)
Fix: Clips and adhesive repairs for minor rattles (1-2 hours). Full dashboard replacement if warped (8-12 hours). Often warranty-covered if caught early. Not safety-critical but annoying in a luxury vehicle.
Estimated cost: $200-2,500
Owner tips
Change transmission fluid every 50,000 miles regardless of 'lifetime fill' claims—this 8-speed runs hot and fluid degrades
PHEV models: verify battery warranty coverage (8yr/100k federal minimum) before purchase—out-of-warranty battery repairs are financially devastating
Keep SYNC system updated via WiFi or dealer visits—many backup camera and transmission issues resolved by software alone
Inspect subframe bushings and undercoating annually in salt-belt states—catching corrosion early saves thousands
Decent used buy for the 2.0L EcoBoost under 50k miles with service records; avoid PHEV models unless battery warranty transferable and verified—too much downside risk on depreciated luxury crossovers.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2022 Lincoln Corsair
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Consequence: Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in May 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
BACK OVER PREVENTION:SOFTWARE · 26V123000
2026-03-03
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: The remedy is currently under development. Interim letters, notifying owners of the safety risk, were mailed April 6, 2026. Additional letters will be sent once the final remedy is available, anticipated second quarter of 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 25V510000
2025-08-08
Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Corsair vehicles. Water may enter into the rearview camera connectors, which can cause the rearview camera image not to appear on the display or display a distorted image.
Consequence: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera harness and rearview camera, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 15, 2025. Additional letters will be sent once the final remedy is available, anticipated May 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S83.
BACK OVER PREVENTION:SOFTWARE · 25V442000
2025-06-27
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
ENGINE · 25V345000
2025-06-06
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and Lincoln Corsair vehicles equipped with a Revel Audio System that were repaired incorrectly under recall 22V-953. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An audible warning chime that does not properly alert of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Dealers will update the audio control module software, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C18.
BACK OVER PREVENTION:SOFTWARE · 25V159000
2025-03-14
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 23V-342. The video output may fail, preventing the rearview camera image from displaying.
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S27.
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM) · 25V133000
2025-02-28
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S16.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 25V048000
2025-01-31
Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.
Consequence: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S05.
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM) · 24V954000
2024-12-20
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.
EQUIPMENT:OTHER:LABELS · 24V852000
2024-11-08
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM) · 24V330000
2024-05-10
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.
ENGINE · 23V380000
2023-05-26
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 23V342000
2023-05-12
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the 360-degree camera, free of charge. Owner notification letters were mailed November 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S23. This recall expands and replaces NHTSA recall number 23V-022. Vehicles previously repaired under 23V-022 will need to have the new remedy performed.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 23V022000
2023-01-23
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the image processing module (IPMB) software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed April 25, 2023. Owner notification letters were mailed February 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S02. This recall expands and replaces NHTSA recall number 21V-735. Vehicles previously repaired under 21V-735 will need to have the new remedy performed.
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and 2020-2022 Lincoln Corsair vehicles equipped with a Revel Audio System. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An audible warning chime that does not properly alert of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Dealers will update the audio control module software, free of charge. Owner notification letters were mailed February 7, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C35.
ENGINE AND ENGINE COOLING · 22V484000
2022-07-07
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Ford Motor Company (Ford) is recalling certain 2022 Corsair and 2021-2022 Escape vehicles equipped with a 2.5L Hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the high voltage battery, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Building an app?
Free API access to all this data — 50 requests/day, no card required.