ShopBaseFree forever shop management software for auto repair shops

Try ShopBase Free →

Home/Labor Times/Ford/Thunderbird/1990-2005 3.8L V6

🇬🇧United Kingdom

1990-2005 Ford Thunderbird

3.8L V6

View Torque Specs | View Fluid Specs | View DTC Codes

ev-battery

12V Auxiliary Battery1.2 hrs
Battery Management System (BMS)1.8 hrs
Battery Coolant Flush0.6 hrs
Battery Cooling System Service1.8 hrs
Battery Disconnect Service1.8 hrs
Battery Junction Box1.8 hrs
Battery Thermal Management Module1.8 hrs
DC-DC Converter1.8 hrs
High Voltage Battery Module R&R1.8 hrs
High Voltage Battery Pack R&R1.8 hrs

ev-charging

ignition

ev-motor

ev-cooling

Heat Pump System1.8 hrs
Cabin Heater - PTC1.8 hrs

ev-electrical

ev-brakes

One-Pedal Driving Calibration1.8 hrs
Regenerative Braking Calibration1.8 hrs

emissions

Oxygen Sensor Replacement0.8 hrs

ev-service

Range Optimization Service1.8 hrs

Engine

Electrical

Cooling System

Fuel System

Exhaust

Transmission

Transmission Rebuild - Automatic1.8 hrs
Transmission R&R - Automatic1.8 hrs
Clutch Cable1.8 hrs
Clutch Disc1.8 hrs
Clutch Hydraulic Line1.8 hrs
Clutch Kit5.4 hrs
Clutch Master Cylinder2.4 hrs
Clutch Slave Cylinder2.4 hrs
Dual Mass Flywheel5.4 hrs
Flywheel Replacement5.4 hrs
Flywheel Resurface5.4 hrs
Kickdown Cable1.8 hrs
Manual Trans Fluid Change0.6 hrs
Transmission Rebuild - Manual1.8 hrs
Transmission R&R - Manual1.8 hrs
Neutral Safety Switch1.8 hrs
Overdrive Solenoid1.8 hrs
Pilot Bearing1.8 hrs
Pressure Plate1.8 hrs
Shift Cable1.8 hrs
Shift Fork1.8 hrs
Shift Linkage1.8 hrs
Shift Solenoid - Single1.8 hrs
Shift Solenoids - All1.8 hrs
Synchros - Single Gear1.8 hrs
Synchros - All1.8 hrs
Torque Converter Clutch Solenoid1.8 hrs
Transmission Control Module1.8 hrs
Throw-Out Bearing1.8 hrs
Torque Converter5.4 hrs
Transmission Oil Cooler5.4 hrs
Transmission Cooler Lines5.4 hrs
Transmission Filter1.8 hrs
Transmission Filter and Fluid1.8 hrs
Transmission Fluid Change0.6 hrs
Transmission Flush1.8 hrs
Transmission Input Shaft Bearing1.8 hrs
Transmission Mount1.8 hrs
Transmission Output Shaft Bearing1.8 hrs
Transmission Pan Gasket1.8 hrs
Transmission Range Sensor1.8 hrs
Transmission Speed Sensor - Input1.8 hrs
Transmission Speed Sensor - Output1.8 hrs
Transmission Fluid Change1 hrs
Valve Body1.8 hrs

Drivetrain

Axle Seal - Front3.6 hrs
Axle Seal - Rear3.6 hrs
Axle Shaft - Rear2.4 hrs
CV Axle - Front2.4 hrs
CV Axle - Rear2.4 hrs
CV Axle Replacement1.5 hrs
CV Axles - Front Pair2.4 hrs
CV Boot - Inner1.8 hrs
CV Boot - Outer1.8 hrs
Differential Cover Gasket1.8 hrs
Differential Fluid Change - Front1.8 hrs
Differential Fluid Change - Rear1.8 hrs
Differential Pinion Seal1.8 hrs
Differential Fluid Change3.6 hrs
Differential Rebuild - Front3.6 hrs
Differential Rebuild - Rear3.6 hrs
Driveshaft2.4 hrs
Driveshaft Center Support Bearing2.4 hrs
Driveshaft - Front2.4 hrs
Driveshaft - Rear2.4 hrs
Limited Slip Clutch Pack1.8 hrs
Ring and Pinion1.8 hrs
U-Joint2.4 hrs
Wheel Bearing Hub - Front2.4 hrs
Wheel Bearing - Press-In Front2.4 hrs
Wheel Bearing - Press-In Rear2.4 hrs
Wheel Bearing Hub - Rear2.4 hrs
Wheel Hub - Front1.8 hrs
Wheel Hub - Rear1.8 hrs
Wheel Studs1.8 hrs

Steering

Center Link/Drag Link1.8 hrs
Electric Power Steering Module1.8 hrs
Electric Power Steering Motor1.8 hrs
Idler Arm1.2 hrs
Pitman Arm1.8 hrs
Power Steering Fluid Flush0.5 hrs
Power Steering Gear Box2.4 hrs
Power Steering Pump Pulley2.4 hrs
Power Steering Pump2.4 hrs
Power Steering Rack2.4 hrs
Power Steering Fluid Flush1.8 hrs
Power Steering Hose - High Pressure1.8 hrs
Power Steering Hose - Return1.8 hrs
Power Steering Reservoir1.8 hrs
Rack and Pinion Boots1.8 hrs
Steering Angle Sensor1.8 hrs
Steering Column2.4 hrs
Steering Coupler1.8 hrs
Steering Damper1.8 hrs
Steering Shaft - Intermediate2.4 hrs
Steering Shaft - Upper2.4 hrs
Steering Wheel1.8 hrs
Tie Rod Assembly1.8 hrs
Tie Rod End Replacement1 hrs
Tie Rod End - Inner1.8 hrs
Tie Rod End - Outer1.8 hrs
Tie Rods - Both Sides1.8 hrs

Suspension

Air Line1.8 hrs
Air Spring/Air Bag1.8 hrs
Air Suspension Compressor1.8 hrs
Air Suspension Height Sensor1.8 hrs
Air Suspension Valve Block1.8 hrs
Ball Joint - Lower2.4 hrs
Ball Joint Replacement1.5 hrs
Ball Joint - Upper2.4 hrs
Ball Joints - Upper and Lower2.4 hrs
Coil Spring - Front1.8 hrs
Coil Spring - Rear1.8 hrs
Coil Springs - Front Pair1.8 hrs
Coil Springs - Rear Pair1.8 hrs
Control Arm Bushing - Front Lower2.4 hrs
Control Arm Bushing - Front Upper2.4 hrs
Control Arm Bushing - Rear2.4 hrs
Front Strut - Single1.8 hrs
Front Struts - Pair1.8 hrs
Knuckle/Spindle - Front3.6 hrs
Knuckle/Spindle - Rear3.6 hrs
Lateral Arm1.8 hrs
Leaf Spring1.8 hrs
Leaf Spring Bushing1.8 hrs
Leaf Spring Shackle1.8 hrs
Leaf Spring U-Bolt Kit1.8 hrs
Lower Control Arm2.4 hrs
Lower Control Arm - Front2.4 hrs
Lower Control Arm - Rear2.4 hrs
Panhard Bar/Track Bar1.8 hrs
Radius Arm1.8 hrs
Radius Arm Bushing1.8 hrs
Rear Shock - Single1.8 hrs
Rear Shocks - Pair1.8 hrs
Shock Absorber Replacement1.2 hrs
Strut Assembly - Front1.8 hrs
Strut Assembly - Rear1.8 hrs
Strut Bearing1.8 hrs
Strut Mount - Front1.8 hrs
Strut Mount - Rear1.8 hrs
Strut Replacement (Front)2 hrs
Strut Replacement (Rear)1.5 hrs
Subframe3.6 hrs
Subframe Bushing3.6 hrs
Sway Bar Bushing - Front1.8 hrs
Sway Bar Bushing - Rear1.8 hrs
Sway Bar - Front1.8 hrs
Sway Bar Link - Front1.8 hrs
Sway Bar Link - Rear1.8 hrs
Sway Bar Links - Front Pair1.8 hrs
Sway Bar - Rear1.8 hrs
Torsion Bar1.8 hrs
Torsion Bar Adjustment1.8 hrs
Trailing Arm3.6 hrs
Trailing Arm Bushing3.6 hrs
Upper Control Arm2.4 hrs
Upper Control Arm - Front2.4 hrs
Upper Control Arm - Rear2.4 hrs
Wheel Bearing Replacement (Front)1.5 hrs
Wheel Bearing Replacement (Rear)1.5 hrs

Brakes

HVAC / Climate

Body

Interior

Armrest1.8 hrs
Carpet1.8 hrs
Center Console1.8 hrs
Dash Pad1.8 hrs
Dashboard1.8 hrs
Door Armrest1.8 hrs
Door Panel1.8 hrs
Floor Mat Hooks1.8 hrs
Glove Box1.8 hrs
Glove Box Latch1.8 hrs
Headliner1.8 hrs
Pedal Pads1.8 hrs
Rearview Mirror1.8 hrs
Seat Belt1.8 hrs
Seat Belt Buckle1.8 hrs
Seat Belt Pretensioner1.8 hrs
Seat Cover1.8 hrs
Seat Foam1.8 hrs
Seat - Front1.8 hrs
Seat - Rear1.8 hrs
Seat Track1.8 hrs
Shifter Boot1.8 hrs
Shifter Knob1.8 hrs
Steering Wheel Cover1.8 hrs
Sun Visor1.8 hrs

Maintenance