2002 ACURA MDX

Typical onset: 80,000-150,000 mi

Symptoms: Harsh or delayed 2-3 shift, especially when cold, Slipping under acceleration or complete loss of forward gears, Burnt ATF smell and dark brown/black fluid, Check engine light with P0730, P0740, P1738 codes

Fix: These 5-speed autos have weak clutch packs and poor cooling design. Rebuild with updated parts runs 12-16 hours labor, but many shops recommend replacement with updated later-gen unit or remanufactured trans due to high re-failure rate on rebuilds. Flush and filter service every 30k can delay but not prevent.

Estimated cost: $2,800-4,500

Typical onset: 120,000-180,000 mi

Symptoms: Excessive oil consumption (1 qt per 1,000 mi or worse), Misfires on cylinders 1, 4, or 6 (the deactivating cylinders), Blue smoke on startup or acceleration, Fouled spark plugs repeatedly on same cylinders, Rattling or knocking from top end

Fix: The early VCM system causes uneven cylinder wear, ring land damage, and piston scoring on cylinders that deactivate. Oil starvation during deactivation cycles is the culprit. Requires complete engine rebuild or replacement—we're talking pistons, rings, honing, valve job. 25-35 hours labor for in-chassis rebuild. VCM disabler modules ($300) can prevent progression if caught early.

Estimated cost: $4,500-7,500

Typical onset: 100,000-160,000 mi

Symptoms: ATF puddle under front of vehicle, passenger side, Low transmission fluid warnings or slipping, Visible corrosion or green crusty buildup on steel cooler lines, Drips after sitting overnight

Fix: The hard steel cooler lines rust from road salt and corrosion where they connect to the radiator. Replacement requires dropping subframe for access—it's not a quick job. 4-6 hours labor including fluid refill and proper purge procedure. Replace both lines even if only one is leaking; the other is right behind it.

Estimated cost: $600-1,100

Typical onset: 90,000-130,000 mi

Symptoms: Clunking over bumps from front end, Steering wheel vibration or shimmy at highway speeds, Uneven inner tire wear, Wandering or loose steering feel

Fix: The large rubber compliance bushings in the front lower control arms crack and tear, especially in cold climates. Requires pressing out old bushings and pressing in new—most shops replace the entire control arm assemblies (2.5-3 hours per side). Do alignment immediately after. Often paired with bad outer tie rod ends.

Estimated cost: $700-1,200

Typical onset: 110,000-160,000 mi

Symptoms: Power steering fluid drips on passenger side of engine bay, Whining or groaning noise when turning at low speeds, Burning smell from fluid hitting hot exhaust manifold, Low fluid level requiring frequent top-offs

Fix: The front seal on the pump deteriorates and weeps fluid onto the front engine mount and down to the subframe. Replacement pump is straightforward—2.5-3 hours including system flush and bleed. OE Acura pumps last longest; aftermarket rebuilds often fail within a year.

Estimated cost: $450-750

Typical onset: 105,000+ mi

Symptoms: Sudden no-start condition, Rough idle or loss of power, Coolant leak from front of engine, Catastrophic engine damage if belt breaks (interference engine)

Fix: The J35 is an interference engine—if the belt snaps, valves meet pistons and you're looking at bent valves minimum, possibly cracked pistons. Honda spec is 105k miles. Service includes belt, water pump, tensioner, seals—6-8 hours labor. If the belt has broken, add 15-25 hours for head removal, valve replacement, and reassembly. This is 100% preventable.

Estimated cost: $800-1,200 preventive | $3,500-6,000 if broken