The 2023 Audi S6 uses the EA839 2.9L twin-turbo V6 platform shared with the RS5 and SQ5. While relatively new, early catastrophic engine failures have emerged—likely due to oil starvation under high load or defective internal components—requiring complete rebuilds at shockingly low mileage.
Symptoms: Sudden knocking or rattling from engine bay under acceleration, Metal shavings in oil during routine change, Loss of oil pressure warning on dash, Complete engine seizure in worst cases
Fix: Full engine rebuild or short block replacement required. 25-35 labor hours for R&R plus machine work. Audi has covered some under warranty but many fall just outside coverage or are blamed on 'abuse.' Extended oil change intervals and aggressive driving under warranty period appear to be contributing factors.
Estimated cost: $18,000-28,000
Transmission Oil Cooler Leaks
Occasional · medium severity
Typical onset: 40,000-70,000 mi
Symptoms: Transmission fluid puddles under vehicle (red/brown fluid), Transmission overheat warnings on dash during spirited driving, Burnt transmission fluid smell, Slipping or delayed shifts when hot
Fix: Oil cooler lines or cooler itself develops leaks at crimped connections. Requires dropping undertray and sometimes removing front bumper for access. 4-6 labor hours. OEM parts only—aftermarket doesn't hold up to pressures.
Estimated cost: $1,200-2,200
Transmission Mount Failure
Common · low severity
Typical onset: 30,000-60,000 mi
Symptoms: Clunking when shifting from Park to Drive or Reverse, Excessive vibration at idle in gear, Visible transmission sag when inspecting from below, Increased cabin NVH during acceleration
Fix: The upper transmission mount deteriorates quickly due to the torque from launch control and aggressive starts. Simple replacement, 2-3 labor hours with proper lift access. OEM Lemforder mount recommended—aftermarket rubber compounds crack faster.
Estimated cost: $450-750
High-Pressure Fuel Pump Failure
Occasional · high severity
Typical onset: 50,000-80,000 mi
Symptoms: Rough idle and misfires under load, Limp mode activation with fuel system fault codes (P0087, P228D), Hard starting or extended cranking when engine is hot, Loss of power above 4,000 RPM
Fix: HPFP on the EA839 is cam-driven and sits in the valley. Requires removing intake manifold and dealing with coolant system. 6-8 labor hours. Fuel filter typically replaced simultaneously as contamination often contributes to failure.
Estimated cost: $2,800-4,200
Carbon Buildup on Intake Valves
Common · medium severity
Typical onset: 60,000-90,000 mi
Symptoms: Rough cold starts with misfires for first 30 seconds, Loss of power and throttle response, Check engine light with multiple misfire codes, Increased fuel consumption
Fix: Direct injection with no port injection means no fuel washing over valves. Walnut blasting both banks required. Intake manifold removal, 8-10 labor hours. This is maintenance, not a defect, but Audi doesn't publicize the interval. Expect to do this every 60-80k miles on these engines.
Estimated cost: $1,200-1,800
Rear Camera System Failure (Under Recall)
Occasional · low severity
Symptoms: Rear camera display shows 'camera unavailable' message, Blank screen or frozen image when shifting to Reverse, Intermittent camera operation in cold weather
Fix: NHTSA recall for backup camera system software or hardware fault. Dealer-only repair, typically software update or camera module replacement. 1-2 labor hours. Should be covered under recall at no cost.
Estimated cost: $0 (recall)
Owner tips
Change oil every 5,000 miles regardless of what the computer says—extended intervals are killing these engines prematurely
Avoid launching or hard pulls until oil temp is above 180°F; cold-start bearing failures are disproportionately common
Budget $2,000/year for maintenance beyond basics; this is a high-strung twin-turbo platform that nickel-and-dimes you
Get a pre-purchase inspection focusing on oil analysis and borescope inspection of cylinders if buying used with any track or performance driving history
Stunning performance and tech, but the early engine failures at low mileage are deeply concerning—only buy with a bulletproof extended warranty or if you're prepared for a potential $20k engine rebuild before 60k miles.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: AGM required for start-stop system; battery located in trunk under floor panel
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2020-2023 Audi S6 — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
⚠️ Software function; uses navigation data for efficiency optimization
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 25V900000
2025-12-19
Volkswagen Group of America, Inc. (Audi) is recalling certain 2019-2026 vehicles. Please see the recall report for a complete list of models. A software error may prevent the rearview camera image from displaying as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the software, free of charge. Owner notification letters were mailed January 14, 2026. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 90TV. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 23, 2025.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2023 Audi S6 2.9L Twin-Turbo V6 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.