The 2012 740i with the N55 engine is a sophisticated luxury sedan that suffers from catastrophic timing chain and fuel injector failures, plus transmission cooler line issues that can destroy the transmission if ignored. These are expensive platforms where deferred maintenance becomes catastrophic quickly.
Timing Chain Guide and Tensioner Failure Leading to Engine Destruction
Common · high severity
Typical onset: 80,000-120,000 mi
Symptoms: Cold start rattle for 2-3 seconds that progressively worsens, Metallic rattling from front of engine under acceleration, Check engine light with timing correlation codes, Sudden catastrophic failure with metal shavings in oil
Fix: Timing chain, guides, tensioner, and sprockets replacement requires 18-22 hours labor. If chain jumps timing or breaks, expect valve-to-piston contact requiring head work or complete engine replacement. Many owners discover this too late and face short block or longblock replacement instead.
Estimated cost: $4,500-8,000 for preventive replacement; $12,000-18,000 for engine rebuild/replacement after failure
High-Pressure Fuel Pump and Injector Failure
Common · high severity
Typical onset: 60,000-100,000 mi
Symptoms: Extended cranking before start, especially when hot, Rough idle with misfires and fuel trims maxed out, Limp mode or no-start when pump fails completely, Metal contamination in fuel system from pump disintegration
Fix: High-pressure fuel pump (HPFP) on N55 can grenade and send metal debris through the system, requiring all six injectors plus fuel rail replacement. Pump alone is 6-8 hours; full fuel system contamination cleanup is 12-16 hours. Always replace pump AND injectors together if metal found.
Estimated cost: $2,800-4,200 for pump and injectors; $1,200-1,800 for pump only if caught early
Transmission Oil Cooler Line Rupture into Radiator
Common · high severity
Typical onset: 70,000-110,000 mi
Symptoms: Milky or strawberry-colored transmission fluid on dipstick, Transmission slipping or erratic shifting, Coolant level dropping with no external leaks, Transmission overheating warnings on iDrive
Fix: Internal cooler lines corrode and leak ATF into coolant or vice versa. Requires radiator replacement, full transmission fluid flush (potentially multiple times), and often transmission replacement if coolant contaminated the valve body. This is a 8-12 hour job if caught early; 20+ hours if transmission is damaged. Do NOT drive once contamination suspected.
Estimated cost: $1,800-3,200 for radiator and flushes; $7,000-11,000 if transmission needs replacement
Valve Cover and Oil Filter Housing Gasket Leaks
Common · medium severity
Typical onset: 50,000-90,000 mi
Symptoms: Oil smell in cabin or under hood after driving, Visible oil seepage on valve cover or around oil filter housing, Oil dripping onto exhaust manifold causing smoke, Low oil warnings between changes
Fix: N55 valve cover gasket and oil filter housing gasket both fail predictably. Valve cover is 4-5 hours including updated PCV system components. Oil filter housing adds another 3-4 hours. Both jobs require upper engine disassembly. Do them together to save labor overlap.
Estimated cost: $1,200-1,800 for valve cover; $800-1,200 for oil filter housing; $1,800-2,600 for both together
Turbocharger Wastegate Rattle and Boost Control Issues
Occasional · medium severity
Typical onset: 80,000-130,000 mi
Symptoms: Rattling noise at idle that disappears under load, Limp mode with underboost or overboost codes, Loss of power above 3,000 RPM, Turbo whistle or excessive shaft play
Fix: Wastegate actuator rod bushings wear causing rattle; vacuum-operated wastegate can also fail electronically. Rattle alone can sometimes be lived with, but boost control failure requires turbo replacement or rebuild. Figure 10-14 hours for turbo R&R on this chassis due to tight engine bay.
Estimated cost: $2,200-3,800 for turbo replacement/rebuild
Active Front Steering (AFS) Module and Sensor Failures
Occasional · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: Yellow steering wheel warning light on dash, Heavy steering at low speeds or parking, Error message 'Active Steering Malfunction', Steering angle sensor requiring constant recalibration
Fix: The active steering motor or control module fails, requiring replacement of the entire steering rack assembly in most cases. This is a 8-10 hour job. Sensor recalibration alone is 1 hour but rarely solves the issue permanently. Some owners delete the system entirely with a manual rack swap.
Estimated cost: $3,500-5,200 for rack replacement; $800-1,200 for sensor/software attempts
Adaptive Air Suspension Compressor and Strut Leaks
Occasional · low severity
Typical onset: 70,000-120,000 mi
Symptoms: Vehicle sagging overnight or after sitting, Suspension compressor running constantly, Ride height errors on iDrive with 'Chassis Malfunction', Audible air leaks near struts or compressor
Fix: Air struts leak at the rubber bellows or internal seals; compressor wears from overwork. Each strut is 2-3 hours; compressor is 3-4 hours. Many owners convert to conventional coils and shocks to eliminate ongoing issues. Air system parts are expensive but failure doesn't strand you—just ride quality suffers.
Estimated cost: $1,800-2,600 per strut; $1,400-2,000 for compressor; $2,500-3,500 for coilover conversion
Owner tips
Change oil every 5,000 miles with quality 5W-30 full synthetic—the 10k interval is engine death on N55s with timing chain wear
Inspect timing chain at 60k miles with a borescope or stethoscope; replace proactively before 100k to avoid engine replacement
Check transmission fluid color every oil change—milky fluid means immediate radiator replacement before trans is damaged
Budget $3,000-5,000 annually for maintenance and repairs after 80k miles; these are not cheap to own out of warranty
Only buy if you have $8k-10k in reserves for inevitable timing chain and fuel system work, or walk away and get a Lexus LS instead—this platform will humble your wallet.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: AGM battery required; located in trunk; register battery with vehicle after replacement
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2011-2015 BMW 740i — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
⚠️ Separate modules for driver and passenger. Memory seat, heating, ventilation, massage programming.
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
POWER TRAIN:DRIVELINE:CONSTANT VELOCITY JOINT · 17V067000
2017-02-02
BMW of North America, LLC (BMW) is recalling certain 2011-2012 135i Coupe, 1 Series M Coupe and 135i Convertible vehicles, 2011 Z4 sDrive 35i, 335i, 335d, 335i Coupe, 335is Coupe, 335i Convertible, 335is Convertible, 535i, 535i xDrive, 535i Gran Turismo and 550i xDrive Gran Turismo vehicles and 2012 740i and 740Li vehicles. The rear driveshaft constant velocity (CV) joint on the affected vehicles may fatigue and break.
Consequence: If the CV joint breaks, the vehicle may have a loss of propulsion, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the rear driveshaft CV joint and, based on its production date, will replace it, free of charge. The recall began April 21, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Performance
Horsepower
315hp
Torque
330lb-ft
0–60 mph
5.7sec
Quarter mile
14.2sec
Top speed
130mph
Fuel economy (EPA)
City
17mpg
Highway
25mpg
Combined
20mpg
Fuel
Premium Gasoline
Capability & size
Curb weight
4,365lb
EPA class
Large Cars
Wiper blades
F01 generation (2009-2015). Sedan body style has no rear wiper. Uses BMW push-button attachment.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2012 BMW 740i 3.0L I6 Turbo N55 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.