The 2020 Silverado 2500HD is a capable heavy-duty truck, but the L8T gas engine has documented catastrophic piston-skirt failures, while the Duramax L5P is significantly more reliable. Transmission oil cooler leaks are a known weak point across both powertrains.
L8T 6.6L Gas Engine Piston Skirt Failure (Catastrophic)
Occasional · high severity
Typical onset: 30,000-80,000 mi
Symptoms: heavy metallic knocking especially when cold, loss of power under load, metal shavings in oil, sudden engine seizure in severe cases
Fix: Complete engine rebuild or short-block replacement required. Pistons crack at the skirt, contaminating oil with aluminum debris. TSB covers some cases under powertrain warranty extension, but out-of-pocket requires 25-35 labor hours for R&R plus machine work.
Estimated cost: $8,000-15,000
Allison 10-Speed Transmission Oil Cooler Line Leak
Common · medium severity
Typical onset: 50,000-90,000 mi
Symptoms: transmission fluid puddle under driver side, fluid level dropping on dipstick, burnt smell if fluid contacts exhaust, transmission temperature warning in severe cases
Fix: Cooler lines corrode where they connect at radiator and transmission. Requires replacing both metal lines and refreshing fluid. 3-4 labor hours including proper fill/bleed procedure.
Estimated cost: $600-1,200
Transmission Mount Failure (10-Speed)
Occasional · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: harsh clunk when shifting into Drive or Reverse, vibration at idle in gear, visible sagging of transmission tailhousing, driveline shudder during acceleration
Fix: Rubber isolator in rear transmission mount deteriorates from heat and load cycles, especially in trucks used for towing. Requires transmission support and 2-3 hours for proper replacement.
Estimated cost: $400-700
Duramax L5P Fuel Filter Housing Air Intrusion
Occasional · medium severity
Symptoms: hard starting after sitting overnight, rough idle for 30-60 seconds after cold start, intermittent loss of power, white smoke on startup
Fix: Factory fuel filter head O-rings allow air into system. Replace filter housing assembly or upgrade to aftermarket aluminum head with better seals. 1.5-2 hours labor including prime/bleed.
Estimated cost: $300-600
DEF System Heater Failure (Duramax)
Occasional · medium severity
Typical onset: 70,000-110,000 mi
Symptoms: 'DEF system fault' message in cold weather, reduced engine power mode below 20°F, DEF quality warning despite fresh fluid, countdown to speed limitation
Fix: DEF tank heater element fails, preventing proper fluid temperature for injection. Requires dropping DEF tank and replacing heater assembly. 4-5 hours labor in cold-weather states where this is common.
Estimated cost: $800-1,400
FICM (Fuel Injection Control Module) Connector Corrosion - L5P
Rare · high severity
Symptoms: intermittent no-start with no crank, random misfires across multiple cylinders, P0087 fuel rail pressure codes, complete engine shutdown while driving
Fix: FICM connector under valve cover exposed to moisture develops corrosion on pins. Requires valve cover removal, connector replacement, and pin cleaning. 3-4 hours labor, worse if corrosion has damaged module.
Estimated cost: $500-2,000
Owner tips
If buying a gas 2020 model, verify engine rebuild history or expect to budget for one — the L8T piston issue is real
Duramax buyers: use quality diesel fuel from high-volume stations and change fuel filter every 15k to protect CP4.2 injection pump
Check transmission cooler lines annually for seepage — catching them early prevents $3k transmission damage from running low on fluid
DEF system: only use fresh DEF from sealed containers, never bulk pumps older than 6 months, especially critical in this model year
Buy the Duramax version without hesitation if maintenance history is clean; avoid the 2020 L8T gas engine entirely unless it's already had the shortblock replaced under warranty.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Unlock any single procedure for $3 — or become the founding sponsor and we generate every common job on this Silverado 2500HD, with your name on each one.
Fitment notes: HD diesel requires high-CCA AGM battery; dual battery system on some configurations
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2020-2024 Chevrolet Silverado 2500HD — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
📍 Under left side of instrument panel, near steering column
🔧 GDS2 + Techline Connect
⚠️ Factory integrated trailer brake controller. Requires calibration for trailer weight. Enhanced features 2020+.
Fuel Pump Control Module (FPCM)0.8 hr R&Rrelearn only +0.2 hr▸ programming details
📍 Under vehicle, mounted to frame rail near fuel tank
🔧 GDS2 or advanced aftermarket scan tool
⚠️ Controls fuel pump speed based on demand. Self-learns after installation.
Headlamp Control Module (HCM)0.8 hr R&Rdealer / factory tool +0.3 hrwith automatic headlamps or LED lighting▸ programming details
📍 Behind left headlamp assembly in engine compartment
🔧 GDS2 + Techline Connect
⚠️ Controls automatic headlamp operation, daytime running lamps, and LED headlamp functions.
Seat Control Module (SCM)0.8 hr R&Rrelearn only +0.2 hrwith power seats and memory function▸ programming details
📍 Under driver seat, mounted to seat frame
🔧 GDS2 or none (self-learning)
⚠️ Controls power seat adjustment and memory positions. Self-learns memory positions after replacement.
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2020 Chevrolet Silverado 2500HD 6.6L V8 Duramax L5P and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.