1978 CHRYSLER NEWPORT

Typical onset: 60,000-120,000 mi

Symptoms: Hard starting when warm or cold, Hesitation and stumbling during acceleration, Stalling at idle or when coming to a stop, Check engine light or no-start with spark issues

Fix: The Lean Burn computer and pickup coil assembly fail frequently. Most techs convert to traditional points or electronic ignition with aftermarket kit. Computer replacement alone runs 2-3 hours labor, full conversion 3-4 hours.

Estimated cost: $400-800

Typical onset: 80,000-140,000 mi

Symptoms: Rattling noise from front of engine on cold start, Loss of power and poor fuel economy, Backfiring through carburetor, Engine runs but timing is severely retarded

Fix: All these V8s use nylon-coated timing gears that deteriorate. Timing set replacement requires front cover removal, new chain, gears, and seal. Book time 5-6 hours, more if you find worn cam or crank gears requiring machine work.

Estimated cost: $650-1,200

Symptoms: Battery light on or flickering, Overcharging (above 15 volts) or undercharging, Dead battery after sitting overnight, Ammeter showing extreme discharge or charge

Fix: The electronic regulator mounted on firewall or inner fender fails from heat and corrosion. Simple bolt-on replacement takes 0.5 hours, but diagnosis can add time if alternator is also suspect.

Estimated cost: $120-250

Typical onset: 70,000-100,000 mi

Symptoms: Poor idle quality and hunting, Flooding or fuel leaking from base, Rough acceleration with flat spots, Excessive fuel consumption

Fix: The Thermoquad plastic fuel bowls warp, and both carbs suffer from aged accelerator pump diaphragms and warped gaskets. Rebuild kits available but proper rebuild requires 3-4 hours for cleaning, setting float levels, and adjustment. Many shops just swap for a basic Edelbrock.

Estimated cost: $350-700

Typical onset: 90,000-130,000 mi

Symptoms: Shuddering during highway cruise around 45-55 mph, Check engine light related to lockup solenoid, Transmission overheating on long trips, No lockup engagement, higher RPM at cruise

Fix: The lockup torque converter and solenoid system added in '78 fails frequently. Solenoid replacement is 2 hours with pan drop, but if converter clutch is burnt, it's a transmission-out job at 8-10 hours.

Estimated cost: $300-2,200

Typical onset: 80,000-120,000 mi

Symptoms: Clunking over bumps from front end, Uneven tire wear on inside edges, Wandering steering and poor alignment retention, Vehicle sits lower on one side

Fix: Upper and lower ball joints, control arm bushings, and sway bar links wear out. Complete front end rebuild with alignment takes 6-8 hours. Torsion bars rarely fail but adjusters seize.

Estimated cost: $800-1,400

Symptoms: Fuel gauge reads empty or full constantly, Erratic gauge movement, Fuel starvation or no-start despite fuel in tank, Visible rust in fuel filter

Fix: Tank-mounted sending units corrode and in-tank sock filters clog with sediment from 45-year-old tanks. Requires tank drop, 2-3 hours labor. If tank has internal rust, replacement recommended.

Estimated cost: $350-900