The 2022 Mustang spans three wildly different powertrains—the EcoBoost turbo four, naturally-aspirated Coyote V8, and supercharged Predator GT500. The platform itself is mature (S550 generation ending), but the turbo four has boost-related failures and the high-output engines can grenade internals when abused or tracked hard.
2.3L EcoBoost Low-Speed Pre-Ignition (LSPI) and Piston Failure
Occasional · high severityTypical onset: 30,000-70,000 mi
Symptoms: sudden loss of power under acceleration, metallic knocking or rattling from engine, check engine light with misfire codes, oil consumption spikes
Fix: EcoBoost engines under high load at low RPM can experience pre-ignition that cracks piston ringlands. Requires engine teardown, piston replacement, often rings and bearings. 18-24 labor hours for full internal refresh. Some get short-block replacement under extended warranty if caught early.
Estimated cost: $5,500-9,000
MT82 Manual Transmission Grinding and Lockout (2.3L and 5.0L)
Common · medium severityTypical onset: 40,000-80,000 mi
Symptoms: grinding into third or fourth gear, gear lockout (won't go into gear), notchy shift action especially when warm, transmission fluid smells burnt
Fix: The MT82 has weak synchronizers and shift fork detent springs. Third and fourth gears wear prematurely. Typical fix is synchro hub replacement, shift fork springs, new fluid. 6-8 hours labor. Some owners opt for full rebuild or MT82-D4 updated parts.
Estimated cost: $1,800-3,200
5.0L Coyote Tick/Valvetrain Noise
Common · low severitySymptoms: ticking or tapping from engine at idle, noise louder when cold, persists after warm-up, no performance loss initially
Fix: Gen 3 Coyote engines have direct injection and variable cam timing that create normal mechanical noise, but excessive tick often traces to sticking cam phasers or weak valve springs. Diagnosis requires listening with stethoscope. Cam phaser replacement is 8-10 hours; valve spring job adds another 6-8 hours if heads come off.
Estimated cost: $1,200-4,500
10-Speed Automatic Harsh Shifts and Shudder (10R80)
Occasional · medium severityTypical onset: 20,000-60,000 mi
Symptoms: hard downshift from 3rd to 2nd, transmission shudder during light acceleration, delayed upshift or hunting between gears, check engine light with transmission codes
Fix: The 10R80 can develop torque converter shudder or adaptive shift issues. Ford issued software updates (TSB 21-2367) that help, but some units need torque converter replacement or valve body work. Flush and software flash is 2 hours; torque converter swap is 8-10 hours.
Estimated cost: $400-3,500
Electric Power Steering (EPAS) Failure and Recall
Occasional · high severitySymptoms: sudden loss of power steering assist, steering warning light, heavy steering effort especially at low speed, clicking from steering column
Fix: EPAS control module or steering gear motor can fail, sometimes related to NHTSA recalls. Rack replacement is 4-5 hours; control module swap is 2 hours. Check for open recalls before diagnosing. Software updates fix some cases.
Estimated cost: $800-2,800
5.2L Predator GT500 Overheating on Track (Supercharged Only)
Rare · high severityTypical onset: any mileage if tracked
Symptoms: coolant temp spikes on track, reduced power mode after 15-20 minutes hard driving, heat soak affecting intake air temps, transmission overtemp warnings
Fix: GT500 has marginal cooling for sustained track use. Owners add oil cooler, transmission cooler, heat exchanger upgrades. Factory trans cooler line failures documented. OEM trans cooler replacement is 3-4 hours; aftermarket cooling upgrades add 6-10 hours depending on kit.
Estimated cost: $1,500-5,000
Rear Differential Bushing Wear and Clunk
Common · low severityTypical onset: 50,000-90,000 mi
Symptoms: clunk from rear end on throttle lift or application, axle wind-up feeling during hard launches, vibration under acceleration
Fix: Independent rear suspension (IRS) uses rubber diff bushings that tear under hard use. Rear subframe must drop to replace bushings. 4-6 hours labor. Performance Pack or GT350 aluminum bushings upgrade available.
Estimated cost: $600-1,200
The 2022 Mustang is a solid buy if it's been adult-owned and maintained, but avoid EcoBoosts with unknown service history and any high-output V8 that's been tracked without cooling upgrades—those grenade expensively.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.