1991 FORD TAURUS

Typical onset: 80,000-120,000 mi

Symptoms: Harsh 1-2 or 2-3 shifts, slipping between gears, No reverse or delayed engagement into drive, Transmission fluid burnt smell, dark brown or black fluid, Check engine light with shift solenoid codes

Fix: AXOD is notoriously weak—internal clutches and bands wear prematurely. Rebuild requires 8-12 hours labor, often not cost-effective. Most owners opt for remanufactured unit swap (6-8 hours). Cooler lines and cooler itself often need replacement simultaneously.

Estimated cost: $1,800-3,200

Typical onset: 100,000-150,000 mi

Symptoms: White smoke from exhaust, sweet smell, Coolant loss with no visible leaks, overheating, Milky oil on dipstick or oil cap, Rough idle, misfires on cylinders 1, 2, or 3

Fix: Vulcan V6 head gaskets leak externally and internally. Both heads typically need resurfacing (warping common). Job requires 10-14 hours—timing cover, intake manifold, exhaust manifolds all come off. Replace water pump, thermostat, and hoses while in there or you'll be back in six months.

Estimated cost: $1,500-2,800

Typical onset: 70,000-110,000 mi

Symptoms: Transmission fluid puddle under front of vehicle, Fluid level drops rapidly, transmission slips when low, Visible rust or wetness on steel cooler lines near radiator

Fix: Steel lines rust through where they connect to radiator-mounted cooler. Replace both lines (not just the leaking one—the other is close behind). 2-3 hours labor. Critical because low fluid kills the already-fragile AXOD in under 50 miles.

Estimated cost: $250-450

Symptoms: Clunking or popping from front end over bumps, Steering feels loose or vague, wandering at highway speed, Visible rust perforation on front subframe rails, Front wheel alignment won't hold, tire wear accelerates

Fix: Salt-belt cars suffer subframe rot at control arm mounting points and steering rack mounts. Subframe replacement requires 8-12 hours (engine support, all suspension components removed). Some frames can be plated/reinforced but it's temporary. This is a structural safety issue—don't ignore clunking.

Estimated cost: $1,200-2,500

Typical onset: 60,000-90,000 mi

Symptoms: Clunking or knocking when turning steering wheel at low speed, Creaking noise from front suspension over bumps, Steering returns slowly to center after turns

Fix: Top strut mounts wear out predictably. Bearing plate separates or rubber isolator cracks. Replace both sides simultaneously (2.5-3.5 hours total). Do alignment after. Often coincides with strut replacement—if struts are weak, do it all together.

Estimated cost: $300-550

Symptoms: No-start condition, engine cranks but won't fire, Intermittent stalling, restarts after sitting 10-20 minutes, Fuel pump doesn't prime when key turned to 'on', Check fuel pump fuse and relay—clicking from relay area

Fix: Fuel pump relay (behind driver's side kick panel) fails from heat cycling. Inertia switch (trunk, driver's side) can trip from potholes or get corroded. Relay replacement: 0.3 hours. Switch reset/replacement: 0.5 hours. Diagnosis takes longer than repair—confirm fuel pressure first.

Estimated cost: $120-280

Typical onset: 90,000-130,000 mi

Symptoms: Whining or groaning noise when turning, especially when cold, Steering effort increases, hard to turn at low speeds, Power steering fluid leak from pump or rack boots, Fluid is dark brown or black instead of red

Fix: Pump shaft seals leak, internal vanes wear. Rack develops leaks at inner tie rod boots. Pump replacement: 2-3 hours. Rack replacement: 4-6 hours (alignment required). Flushing system when replacing pump extends life—old fluid eats seals.

Estimated cost: $400-1,200