The 2015 Transit Connect is a practical cargo/passenger van with two significant reliability concerns: the 2.5L I4 engine has catastrophic coolant intrusion issues leading to total engine failure, while the PowerShift dual-clutch automatic transmission suffers from shuddering, slipping, and premature failure across both engine options.
2.5L Duratec Engine Coolant Intrusion and Catastrophic Failure
Common · high severity
Typical onset: 60,000-120,000 mi
Symptoms: White smoke from exhaust on cold starts, Coolant loss with no visible leaks, Milky/contaminated oil on dipstick, Misfires and rough idle that worsens over time, Sudden loss of power or complete engine seizure
Fix: The cylinder head design allows coolant to seep past gasket into cylinders, washing cylinder walls and destroying bearings. By the time symptoms appear, damage is usually done. Requires complete engine rebuild or replacement (short block minimum, often long block). 18-24 labor hours for removal, rebuild/replace, and reinstall. Many shops won't rebuild due to design flaw—replacement is safer.
Estimated cost: $5,500-8,500
PowerShift DPS6 Dual-Clutch Transmission Failure
Common · high severity
Typical onset: 40,000-90,000 mi
Symptoms: Shuddering or jerking during low-speed acceleration (1st to 2nd gear), Slipping between gears or failure to engage, Grinding or clunking noises when shifting, Hesitation or delayed engagement from stop, Burning smell during normal driving
Fix: Ford's DPS6 dry dual-clutch has notorious clutch pack wear and TCM software issues. Early failures often covered by extended warranty (to 7yr/100k), but post-warranty repairs are brutal. Clutch pack replacement requires transmission removal: 8-12 hours. Full transmission replacement when input shaft or mechatronics fail: 10-14 hours. Software updates help but don't solve mechanical wear.
Estimated cost: $2,800-5,200
Transmission Oil Cooler Line Corrosion and Leaks
Occasional · medium severity
Typical onset: 70,000-110,000 mi
Symptoms: Transmission fluid puddles under vehicle (red/pink fluid), Transmission overheating warning light, Fluid level dropping between services, Visible corrosion on cooler lines near radiator
Fix: Steel cooler lines rust through where they mount near subframe, especially in salt-belt states. Requires replacement of corroded sections or entire line assembly. 2-4 hours labor depending on which line fails. Must refill and relearn transmission. Often discovered during other transmission work.
Estimated cost: $400-750
Door Latch Failures and Inoperative Doors
Occasional · medium severity
Symptoms: Door won't open from inside or outside, Door ajar warning stays on when doors are closed, Sliding door won't latch or releases unexpectedly, Door handle pulls but door doesn't open
Fix: Multiple NHTSA recalls address latch pawl spring failures, but non-recalled latches still fail. Sliding doors are worst offenders. Latch replacement requires interior panel removal and latch mechanism R&R. 1.5-3 hours per door depending on which one. Rear barn doors and sliding doors more complex than front doors.
Estimated cost: $350-650
Transmission Mount Failure
Occasional · low severity
Typical onset: 60,000-100,000 mi
Symptoms: Excessive clunking when shifting into Drive or Reverse, Vibration through floorboard at idle in gear, Visible engine/trans movement when accelerating hard, Noise from underneath during hard acceleration
Fix: The rear transmission mount rubber deteriorates and tears, allowing excessive drivetrain movement. Replacement requires supporting transmission and unbolting mount—straightforward job. 1-2 hours labor. Often done alongside transmission work. Inspect all three engine/trans mounts while underneath.
Estimated cost: $250-450
Backup Camera Failure and Display Issues
Occasional · low severity
Symptoms: No backup camera image when in reverse, Intermittent camera display (works sometimes), Lines/static on camera display, Blue screen or 'camera unavailable' message
Fix: Camera module fails internally or wiring corrodes at tailgate/rear door connections. Diagnosis requires checking power/signal at camera and testing display unit. Camera replacement: 1 hour. Wiring repair if harness damaged at hinge points: 1-2 hours. SYNC module update sometimes resolves software glitches.
Estimated cost: $200-500
Owner tips
If buying 2.5L engine model, have pre-purchase inspection include compression test and oil analysis—walk away if any coolant contamination detected
Check transmission fluid condition early and often—dark/burnt smell means clutches are already damaged on DPS6 transmission
PowerShift transmissions with extended warranty coverage (TSB 14-0076) should have all available software updates applied before warranty expires
Inspect door latches during any service—replace proactively if recall was performed over 3 years ago, as replacements also fail
Rust-prone areas: inspect transmission cooler lines, subframe mounts, and rear door hinges annually in salt states
Hard pass on the 2.5L engine due to catastrophic failure risk; the 2.0L with PowerShift transmission is only acceptable with confirmed extended warranty coverage or budgeting $3-5k for eventual transmission work—better commercial van options exist.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2015 Ford Transit Connect
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 25V572000
2025-09-04
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH · 23V502000
2023-07-21
Ford Motor Company (Ford) is recalling certain 2014-2016 Transit Connect vehicles. The front door latch pawl may crack and prevent the door from latching.
Consequence: An unlatched door can open while driving, increasing the risk of injury.
Remedy: Dealers will inspect and replace the front door latches as necessary, free of charge. Owner notification letters were mailed February 2, 2024. Owners may contact Ford customer service 1-866-436-7332. Ford's number for this recall is 23S36.
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) · 22V413000
2022-06-10
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE · 21V631000
2021-08-11
Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.
Consequence: Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.
Remedy: Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) · 21V376000
2021-05-24
Ford Motor Company (Ford) is recalling certain 2013-2021 Transit Connect vehicles equipped with 2.5L engines. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, causing the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the underhood shifter cable bushing, and add a protective cap, free of charge. Owner notification letters were mailed on June 29, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S24.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH · 20V331000
2020-06-08 · RQ19005
Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will inspect the latch date codes to confirm if the repair was done correctly, and replace the side door latches if necessary, free of charge. Owners will also have the option to inspect their own vehicle's door latches and enter the date codes into a website to determine if the latches are correct. Owner notification letters were mailed on July 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S30.
VISIBILITY:SUN/MOON ROOF ASSEMBLY · 20V260000
2020-05-08
Ford Motor Company (Ford) is recalling certain model year 2014-2017 Transit Connect vehicles equipped with a Panoramic Fixed-Glass Vista roof. An improper bond may exist between the panoramic roof and the vehicle body and may result in wind noise, water leak, and in some cases, separation from the vehicle.
Consequence: If the panoramic roof panel separates from the vehicle while it is being driven, it may increase the risk of an injury or crash.
Remedy: Ford will notify owners, and dealers will remove, clean, and reinstall the panoramic roof panel, free of charge. Ford issued owners an interim notification on May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S22.
POWER TRAIN:DRIVELINE:DRIVESHAFT · 19V767000
2019-10-25
Ford Motor Company (Ford) is recalling certain 2015-2017 Transit vehicles. This recall includes all full-size Transit vehicles previously recalled under 17V-408 except ones that received mechanical universal joint (u-joint) as a remedy and any 156" or 178" wheelbase Chassis Cab and Cut-Away bodies models. The flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash or injury.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling every 40,000 miles until the final remedy is available. The final remedy will consist of installation of a driveshaft front section equipped with a mechanical u-joint in place of the flexible coupling. These repairs will be made free of charge. Owner notification letters were mailed on April 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S38. Note: This recall supersedes recall number 17V-408.
SEATS · 19V333000
2019-04-29
New England Wheels (New England) is recalling certain 2014-2018 Ford Transit and 2014-2019 Ram Promaster 2500 and 3500 vehicles modified to be equipped with Freedman Go-ES Foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: New England has notified owners, directing them to contact Freedman for repairs to the foldaway seats, free of charge. The recall began May 27, 2019. Owners may contact Freedman customer service at 1-800-443-4540 or New England at 1-800-886-9247.
SEATS · 19V329000
2019-04-26
Fenton Mobility Products, Inc. (Fenton Mobility) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Fenton Mobility will notify owners, and a Fenton Mobility technician will repair the foldaway seats, free of charge. The recall is expected to begin in June 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014.
SEATS · 19V313000
2019-04-18
Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.
EQUIPMENT ADAPTIVE/MOBILITY · 19V271000
2019-04-03
Mobility Specialists, Inc. (Mobility Specialists) is recalling certain 2014-2017 Ford E-150 and Transit vans modified to be equipped with Ricon S-Series and K-Series wheel chair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Mobility Specialists, working with Ricon, has notified the owners. Ricon will provide instructions and materials for replacing defective parts. Owners may contact Ricon customer service at 1-800-322-2884.
SEATS · 19V247000
2019-03-28
Cabot Coach Builders, Inc. DBA Royale Limousine (Royale) is recalling certain 2015-2018 Ford Transit-based mini-coaches equipped with Freedman GO-ES foldaway seats recalled under 18E-076. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Royale will notify owners and dealers will inspect and repair the seat. The recall began June 6, 2019. Owners may contact Royale customer service at 1-800-544-5587.
SEATS · 19V238000
2019-03-26
Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.
SEATS · 19V229000
2019-03-22
TransitWorks is recalling certain 2015-2018 Ford Transit, 2018 Ford Transit Connect, and 2016 Dodge Ram ProMaster vehicles modified to be equipped with Freedman Seating GO-ES seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: TransitWorks has notified owners and instructed them to contact Freedman seats for a repair kit. The recall began December 19, 2019. Owners may contact Freedman Seating customer service at 1-800-443-4540 or TransitWorks customer service at 1-855-337-9543.
SEATS · 19V205000
2019-03-18
Quality Van Sales, Inc. (Quality Van) is recalling certain 2015-2018 Ford Transit and E-350 vehicles modified to be equipped with Freedman GO-ES Foldaway Seat back cushions. The seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Quality Van will notify owners and dealers will inspect and repair the foldaway seat, free of charge. The recall began March 21, 2019. Owners may contact Quality Van customer service at 1-800-408-8550.
EQUIPMENT ADAPTIVE/MOBILITY · 19V183000
2019-03-06
Fenton Mobility Products, Inc. (Fenton) is recalling certain 2015-2017 Ford Transit passenger vans modified to be equipped with Ricon S & K Titanium Wheelchair Lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Fenton will notify owners, and a service technician will install Ricon Recall Parts Kit RI61396, free of charge. The recall began April 24, 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014. Fenton's number for this recall is RI61396.
POWER TRAIN:DRIVELINE:DRIVESHAFT · 19V103000
2019-02-21
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
SEATS · 18V782000
2018-11-06
National Van Builders, Inc. (National Van) is recalling certain 2015-2018 Ford Transit vehicles equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: National Van will notify owners, and dealers will inspect and repair the foldaway seat, free of charge. The recall began November 26, 2018. Owners may contact National Van customer service at 1-508-222-2272.
ELECTRICAL SYSTEM:WIRING · 18V275000
2018-04-30
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Note: This is an expansion of recall 17V-668 (Ford recall 17S34). Ford's number for this recall expansion is 17S34-S1.
ELECTRICAL SYSTEM:WIRING · 17V668000
2017-10-23
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. The recall began on February 9, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S34.
POWER TRAIN:DRIVELINE:DRIVESHAFT · 17V408000
2017-06-26
Ford Motor Company (Ford) is recalling all 2015-2017 Transit vehicles except 156" and 178" wheelbase Chassis Cab and Cut-Away bodies. In the affected vehicles, the flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling on any vehicle with more than 30,000 miles. A final remedy repair of a redesigned flexible coupling or a revised driveshaft equipped with a universal joint is being developed and is expected in early 2018. These repairs will be made free of charge. Interim notifications informing owners of the safety risk were mailed July 21, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S15.
ENGINE AND ENGINE COOLING:ENGINE · 17V209000
2017-03-27
Ford Motor Company (Ford) is recalling certain 2014 Escape, 2014-2015 Fiesta ST, 2013-2014 Fusion and 2013-2015 Transit Connect vehicles equipped with 1.6L GTDI engines. If the vehicle is started and driven with an insufficient level of coolant within the engine cooling system, the engine cylinder head may overheat, crack and leak oil.
Consequence: If the cylinder head cracks and leaks oil, the oil may contact a hot engine or exhaust component, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will install a coolant level sensor and the supporting hardware and software, free of charge. Interim notices informing owners of the safety risk were mailed April 21, 2017. The recall began on January 5, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S09.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH · 16V643000
2016-09-06 · PE16001
Ford Motor Company (Ford) is recalling certain model year 2012-2015 Ford Focus, 2013-2015 Ford Escape and Ford C-MAX, 2015 Lincoln MKC and Ford Mustang, and 2014-2016 Ford Transit Connect vehicles. A component within the door latches may break, preventing the doors from latching and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will replace the door latches with an improved part, free of charge. The recall began on January 27, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S30.
FUEL SYSTEM, DIESEL · 16V618000
2016-08-24
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
EQUIPMENT ADAPTIVE/MOBILITY · 16V350000
2016-05-24
New England Wheels (New England) is recalling certain model year 2006-2014 Ford E-250, E-350, and 2015 Ford Transit vans equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Remedy: New England will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 29, 2016. Owners may contact New England customer service at 1-800-886-9247. New England's number for this recall is 16E-020.
EQUIPMENT ADAPTIVE/MOBILITY · 16V331000
2016-05-20
National Van Builders, Inc. (National Van) is recalling certain model year 2015 Ford Transit vehicles manufactured July 1, 2015, to October 30, 2015, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Remedy: National Van will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 15, 2016. Owners may contact National Van customer service at 1-800-527-7477. National Van's number for this recall is Ricon 2016.
AIR BAGS:SIDE/WINDOW · 16V188000
2016-04-04
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured March 12, 2014, to March 18, 2016. In the affected vehicles, the side curtain air bag may not deploy with the proper trajectory due to being folded and packaged incorrectly.
Consequence: A side curtain air bag that does not deploy as intended may increase the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will inspect and re-orient the side curtain air bag assembly, as necessary, free of charge. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S13.
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured February 13, 2014, to January 13, 2016 and equipped with rear passenger seats. The rear seat belt buckles may be damaged if a heavy object is placed on, or impacts, the top of the buckle. The damage may prevent the buckle from latching or from remaining latched.
Consequence: An unlatched seat belt increases the risk of injury to the occupant in the event of a crash.
Remedy: Ford will notify owners, and dealers will modify or replace the seat belt buckles, depending on their location in the vehicle, free of charge. The recall began May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S06.
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT · 15V865000
2015-12-22
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Transit vehicles manufactured May 1, 2015, to June 26, 2015, and equipped with dual rear wheels. The affected vehicles have a left or right rear axle drive shafts that may fracture, resulting in loss of drive power. Additionally, the vehicle may unexpectedly roll if it is parked without the parking brake applied.
Consequence: A loss of drive power or vehicle rollaway after being parked can increase the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will replace the left and right axle drive shafts, free of charge. The recall began February 9, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S37.
SEAT BELTS · 15V402000
2015-06-24
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured March 1, 2015, to April 10, 2015. The affected vehicles may have been built with seat belt assemblies that have seat belt labels that are missing the required belt model and model year and instead state "prototype sample." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) 209, "Seat Belt Assemblies."
Consequence: In the event of a safety issue with the affected seat belts, the vehicle owner may not be able to identify the seat belt if the seat belt label does not include a date of manufacturer.
Remedy: Ford has notified the one fleet owner affected, and a Ford representative will travel to the vehicle locations to install a new label that includes all of the required information. There will be no charge for this service. The recall began on June 12, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C05.
Ford Motor Company (Ford) is recalling certain model year 2014-2015 Ford Escape vehicles manufactured May 19, 2014, to February 6, 2015, and Transit Connect vehicles manufactured May 11, 2014, to July 2, 2015. Due to a software incompatibility issue, the instrument panel cluster be inoperative including a blank multiple functional display (MFD), and non-functional warning chimes, messages and warning lights. Specific warning chimes, messages and warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
Consequence: If the instrument cluster is inoperative, the driver of may not be warned of safety related issues such as low tire pressures or disabled air bags, increasing the risk of personal injury or a crash.
Remedy: Ford will notify owners, and dealers will update the instrument panel software, free of charge. The recall began on August 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C03.
Ford Motor Company (Ford) notified the agency on January 8, 2015, that they are recalling certain model year 2014 Ford Escape vehicles manufactured April 15, 2014, to May 8, 2014, and 2015 Lincoln MKC vehicles manufactured April 21, 2014, to May 15, 2014. On April 30, 2015, Ford expanded the recall to cover an additional 45,505 vehicles, including certain model year 2014-2015 Ford Transit Connect vehicles manufactured November 11, 2013, to August 29, 2014, 2014-2015 Ford Fiesta vehicles manufactured April 10, 2014, to June 17, 2014 and 2014 Ford Edge vehicles manufactured April 30, 2014, to May 21, 2014. Improper nickel plating of components within the fuel pump may result in the fuel pump failing.
Consequence: If the fuel pump fails, the vehicle may stall without warning, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel pump, free of charge. The recall began on February 27, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S30.
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Transit vehicles manufactured July 28, 2014, to August 7, 2014. In the affected vehicles the fuel filter bracket mounting may detach from the frame cross member over time.
Consequence: A separation of the fuel filter from the cross member will disrupt distribution of fuel to the engine, thereby inducing an engine stall. An unexpected engine stall while driving increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will install a reinforcement plate, free of charge. The recall began on December 19, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S23.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS · 14V482000
2014-08-06
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
STRUCTURE:BODY:DOOR · 14V483000
2014-08-06
Ford Motor Company (Ford) is recalling certain model year 2015 Transit cargo vans without rear seating positions manufactured March 12, 2014, to June 24, 2014 and equipped with windowless sliding doors. The affected vehicles may have been manufactured without the epoxy reinforcement on the windowless sliding doors.
Consequence: A sliding door without the epoxy reinforcement has an increased potential of unlatching in certain side impact crashes. A door that unlatches may open, allowing for a vehicle occupant to be ejected in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will install a reinforcement plate into the windowless sliding door, free of charge. The recall began in September 22, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S16.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.