The 2015 Tucson is mostly reliable but plagued by a catastrophic engine failure issue on the 2.4L variant due to metal debris from manufacturing, leading to seized engines and class-action settlements. The 2.0L is generally safer, though both suffer from typical Hyundai automatic transmission aging issues.
Catastrophic Engine Failure (2.4L GDI Theta II)
Occasional · high severity
Typical onset: 60,000-120,000 mi
Symptoms: Knocking or ticking noise from engine block, especially on cold starts, Check engine light with misfire codes (P0301-P0304), Metal shavings in oil during changes, Sudden loss of power or complete engine seizure while driving, Burning oil between changes (1+ quart per 1,000 miles)
Fix: Complete engine replacement or rebuild required; Hyundai extended warranty to 10yr/100k miles for original owners under settlement, but used-car buyers often excluded. Expect 18-24 hours labor for short-block or complete engine swap. Root cause: machining debris left in crankshaft during manufacturing causes bearing failure.
Estimated cost: $5,500-8,500
Transmission Oil Cooler Line Leaks
Common · medium severity
Typical onset: 80,000-130,000 mi
Symptoms: Transmission fluid pooling under vehicle near radiator, Pink or red fluid drips on driveway, Harsh shifting or slipping when fluid gets low, Overheating transmission temp warning
Fix: Replace cooler lines and hoses where they connect to radiator; lines corrode at crimped fittings. Sometimes requires radiator removal for access. 2-3 hours labor plus flush and fluid refill (8-9 quarts ATF).
Estimated cost: $400-700
Transmission Mount Failure
Common · low severity
Typical onset: 70,000-110,000 mi
Symptoms: Clunk or thud when shifting from Park to Drive or Reverse, Vibration at idle that disappears when in Park/Neutral, Excessive engine movement visible from engine bay during acceleration
Fix: Replace transmission mount (hydraulic type); common wear item on this platform. 1.5-2 hours labor, straightforward job but requires supporting transmission.
Estimated cost: $250-400
ABS Module Failure (Recall 18V-226)
Occasional · high severity
Symptoms: ABS and ESC warning lights illuminated on dash, Loss of anti-lock braking function, In rare cases, brake fluid leak from ABS module causing reduced braking power, Engine fire risk if leaking fluid contacts hot components
Fix: Recall repair involves ABS module replacement and installation of relay kit to cut power if short circuit detected. Dealer-only repair, should be free if recall not previously completed. Check VIN for open recall status before purchase.
Estimated cost: $0 (recall) or $1,200-1,800 if out-of-pocket
Direct Injection Carbon Buildup (Both Engines)
Common · medium severity
Typical onset: 90,000-140,000 mi
Symptoms: Rough idle and stumbling on acceleration, Misfires on one or more cylinders (P0300-P0304), Reduced fuel economy (2-4 mpg loss), Hesitation or jerking during light throttle cruising
Fix: Intake valve walnut blasting required; GDI engines have no fuel washing over valves. Service involves removing intake manifold and media-blasting carbon deposits. 4-5 hours labor, should be done every 80-100k miles as preventive maintenance.
Estimated cost: $450-750
Panoramic Sunroof Drain Clogs and Leaks
Occasional · low severity
Symptoms: Water dripping from headliner onto front or rear passengers, Wet carpet in footwells after rain or car wash, Musty smell in cabin, Water stains on headliner fabric
Fix: Clear sunroof drain tubes (run down A-pillars and C-pillars) with compressed air or weed-trimmer line; also inspect drain outlet grommets at bottom for cracks. Sometimes requires headliner removal if mold remediation needed. 1-2 hours labor for drain service only.
Estimated cost: $150-300
Owner tips
If buying a 2.4L model, confirm engine replacement history or proof of Hyundai's extended warranty coverage before purchase—many engines fail catastrophically
Change transmission fluid every 60k miles (not 'lifetime' as Hyundai claims) to extend cooler line and valve body life
Use Top Tier gasoline and occasional Italian tune-up (highway pulls) to minimize carbon buildup on intake valves
Check for open ABS recall before purchase and have dealer complete it immediately—potential fire hazard
Buy the 2.0L only and budget for walnut blasting service; avoid the 2.4L unless engine has been replaced under warranty with updated parts—too much catastrophic failure risk.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: Group H5 is standard for 2015 Tucson 2.0L; battery located in engine compartment
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2011-2015 Hyundai Tucson — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
Motor Driven Power Steering Control Unit (MDPS)2.5 hr R&Raftermarket tool +0.3 hr▸ programming details
📍 Integrated with electric power steering motor assembly on steering column, below dashboard
🔧 Hyundai GDS or Autel/Launch with steering angle sensor calibration
⚠️ Requires steering angle sensor calibration and center position relearn; column must be removed for access
Anti-lock Brake System / Electronic Stability Control Module (ABS/ESC)1.8 hr R&Raftermarket tool +0.3 hr▸ programming details
📍 Engine compartment, driver side inner fender well, mounted to hydraulic control unit
🔧 Hyundai GDS or Autel/Launch with brake bleed procedure
⚠️ Integrated with hydraulic unit; requires brake system bleeding and steering angle sensor calibration after replacement
📍 Driver side lower dashboard, integrated with main fuse/relay box above kick panel
🔧 Hyundai GDS with VIN write and network configuration
⚠️ Handles CAN bus routing and some body control functions; may require multiple module re-registrations after replacement
Engine Control Module / Powertrain Control Module (ECM/PCM)1.2 hr R&Rdealer / factory tool +0.5 hr▸ programming details
📍 Engine compartment, driver side firewall, mounted on bracket below brake master cylinder
🔧 Hyundai GDS with VIN write and immobilizer sync
⚠️ Must perform immobilizer registration and throttle body relearn after replacement
Heating Ventilation Air Conditioning Control Module (FATC/MATC)1.2 hr R&Rrelearn only +0.2 hr▸ programming details
📍 Behind center dashboard HVAC control panel, integrated with control head unit
🔧 Self-relearn procedure via button sequence or Hyundai GDS
⚠️ Automatic climate control (FATC) requires actuator calibration; manual A/C (MATC) is simpler module
Adaptive Front Lighting System Module (AFLS)1.2 hr R&Raftermarket tool +0.3 hrwith adaptive headlights (Limited trim with HID option)▸ programming details
📍 Behind left headlight assembly, integrated with headlight leveling actuator
🔧 Hyundai GDS or Autel/Launch with headlight aiming calibration
⚠️ Requires headlight aiming and steering angle correlation after replacement
Body Control Module (BCM)1.0 hr R&Rdealer / factory tool +0.8 hr▸ programming details
📍 Behind lower left dashboard trim panel, above driver kick panel fuse box
🔧 Hyundai GDS with VIN write and configuration coding
⚠️ Controls lighting, wipers, door locks, power windows; requires full vehicle configuration coding for options
Smart Key Control Module / Immobilizer Control Unit (SKCM/IMM)1.0 hr R&Rdealer / factory tool +1.0 hr▸ programming details
📍 Behind lower center dashboard, above transmission tunnel, near BCM
🔧 Hyundai GDS with immobilizer registration and key programming
⚠️ All keys must be reprogrammed after replacement; requires ECM and BCM synchronization
Telematics Control Unit / Blue Link Module (TCU)1.0 hr R&Rdealer / factory tool +0.5 hrwith Blue Link subscription (2012+ Limited trim)▸ programming details
📍 Behind center dashboard, above center console, near AVN head unit
🔧 Hyundai GDS with VIN write and Blue Link account registration
⚠️ Requires cellular carrier activation and Blue Link account linking after replacement
Supplemental Restraint System Control Module / Airbag Control Unit (SRS/ACU)0.8 hr R&Raftermarket tool +0.2 hr▸ programming details
📍 Center console tunnel, beneath center console trim, between front seats
🔧 Hyundai GDS or Autel/Launch with crash data clear
⚠️ Must clear crash data and verify all airbag circuits after replacement; wait 3 minutes after battery disconnect
📍 Dashboard instrument panel, behind steering wheel, secured with four screws
🔧 Hyundai GDS with VIN write and mileage programming
⚠️ Mileage must be programmed to match vehicle; immobilizer data may require synchronization
Rear View Camera Module (RVC)0.5 hr R&Rno codingwith rear view camera
📍 Integrated into rear liftgate handle assembly, above license plate
⚠️ Plug-and-play replacement; camera alignment is fixed by mounting position
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE · 22V056000
2022-02-03
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Wiper blades
2010-2015 generation (LM/ix35). Standard hook arm attachment.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2015 Hyundai Tucson 2.0L I4 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.