The 2007 ML-Class (W164) is known for catastrophic engine failures on the M273 V8 and transmission concerns across both powertrains. Balance shaft and timing chain issues make the V8 a ticking time bomb after 80k miles, while the 722.9 seven-speed transmission suffers from conductor plate failures and cooler leaks.
Symptoms: Catastrophic engine noise (knocking/rattling) that progresses quickly, Metal shavings in oil, glitter on dipstick, Check engine light with misfire codes before total failure, Complete engine seizure in worst cases
Fix: Balance shaft gears strip teeth, dumping metal through the entire engine and destroying bearings, cylinder walls, and crankshaft. Requires complete engine rebuild or replacement. 25-35 labor hours for short block swap, 40+ for full teardown rebuild.
Estimated cost: $8,000-15,000
M273 V8 Timing Chain Stretch and Guide Failure
Common · high severity
Typical onset: 70,000-110,000 mi
Symptoms: Rattling noise on cold starts lasting 3-10 seconds, Check engine light with cam/crank correlation codes (P0016, P0017), Rough idle and reduced power, Metal particles in oil from guide wear
Fix: Timing chains stretch and guides break apart, causing valve timing issues and potential valve-to-piston contact. Requires both banks done simultaneously with new chains, guides, tensioners, and cam adjusters. 18-24 labor hours.
Symptoms: Harsh shifts or refusal to shift out of 2nd/3rd gear (limp mode), Transmission slipping between gears, Check engine light with gear ratio codes, Erratic shifting patterns, especially when cold
Fix: Internal conductor plate (electrical control module) fails due to heat and fluid contamination. Requires transmission removal, pan drop, valve body removal, and conductor plate replacement with updated 13-pin version. 12-16 labor hours.
Estimated cost: $3,000-4,500
Transmission Oil Cooler Line Leaks
Common · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: Transmission fluid puddles under vehicle near radiator, Low transmission fluid warnings on dash, Burnt transmission fluid smell, Transmission overheating warnings in severe cases
Fix: Rubber sections of cooler lines crack and leak at crimped connections. Lines run along frame rail to front-mounted cooler. Replace both supply and return lines as a set. 3-5 labor hours.
Estimated cost: $800-1,400
M272 V6 Intake Manifold Runner Flap Failure
Occasional · medium severity
Typical onset: 75,000-120,000 mi
Symptoms: Check engine light with P2004, P2005, P2006 runner control codes, Rattling from engine bay at idle, Loss of low-end torque, Metal flap pieces can be sucked into cylinders causing scoring
Fix: Plastic runner flaps break off inside intake manifold due to material fatigue. Requires manifold removal and replacement with updated aluminum manifold design. 6-8 labor hours.
Estimated cost: $1,800-2,800
Front Differential Leaks and Bearing Failure
Occasional · medium severity
Typical onset: 80,000-130,000 mi
Symptoms: Grinding or howling noise from front of vehicle during acceleration, Gear oil leak visible on front differential housing, Vibration through drivetrain at highway speeds, 4MATIC warning light in advanced cases
Fix: Front differential seals leak due to age and wear, leading to low oil and bearing damage if not caught early. Requires differential removal, seal replacement, and bearing service if damaged. 8-12 labor hours for full rebuild.
Estimated cost: $2,000-3,500
Airmatic Suspension Compressor and Strut Failure
Common · medium severity
Typical onset: 70,000-110,000 mi
Symptoms: Vehicle sits low in front or rear, especially after sitting overnight, Airmatic warning on dash with vehicle picture showing low corner, Compressor runs continuously or won't shut off, Rough ride quality from blown air struts
Fix: Air struts develop leaks at rubber bellows, and compressor fails from overwork. Front struts fail more often than rears. Individual strut replacement takes 2-3 hours per corner, compressor is 4-5 hours.
Estimated cost: $1,200-2,000 per strut, $2,000-2,800 compressor
Owner tips
If buying a V8 model, get pre-purchase inspection focusing on oil analysis for metal content and borescope cylinder walls
Change transmission fluid every 40k miles despite Mercedes 'lifetime fluid' claim—conductor plate death is heat-related
Listen for ANY timing chain rattle on M273 engines and walk away—it only gets worse and quickly
Budget $2-3k per year for deferred maintenance on any W164 over 80k miles
V6 models are significantly more reliable than V8s, but still have intake manifold concerns
Hard pass on V8 models unless fully documented engine rebuild already done; V6 is marginal if priced under $8k with service records, but plan for transmission work and suspension rebuilds within 20k miles.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: Battery located under front passenger seat or in engine compartment; AGM technology standard for W164 chassis
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2006-2007 Mercedes-Benz ML — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
📍 Under driver or passenger seat, mounted to seat frame
🔧 Star Diagnosis or Autel
⚠️ Memory seats; separate module per seat; position and massage function calibration recommended
Fuel Pump Control Module (FPCM)no coding
📍 Integrated into SAM-R
⚠️ Controlled by SAM-R; no separate module; SAM-R replacement includes fuel pump control coding
Pre-Safe Control Unit (PSM)no coding
📍 Integrated into SRS module or separate unit near SRS
⚠️ Optional Pre-Safe system; typically integrated into SRS; no separate replacement unless standalone variant
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2007 Mercedes-Benz ML 3.5L V6 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.