The 2007 W221 S550 with the M273 5.5L V8 is a technological marvel that becomes a financial liability once the engine's balance-shaft design flaws manifest. Early M273 engines suffer catastrophic internal wear that often requires full rebuilds or replacement.
Symptoms: Metallic rattling or knocking from engine bay, especially cold start, Metal shavings or glitter in oil during changes, Check engine light with cylinder misfire codes, Catastrophic failure: rod through block, complete seizure
Fix: The balance shaft gears wear prematurely, sending metal debris through the entire engine. Once contaminated, requires complete engine rebuild including pistons, rings, bearings, crank polishing, and head work. 40-60 labor hours for proper rebuild. Many shops recommend reman long-block swap at 25-35 hours instead.
Estimated cost: $12,000-22,000
722.9 Transmission Valve Body / Conductor Plate Failure
Common · high severity
Typical onset: 80,000-150,000 mi
Symptoms: Harsh shifts, especially 2-3 or 3-4, Limp mode with transmission fault codes, Delayed engagement into Drive or Reverse, Slipping between gears under load
Fix: The 722.9 7-speed valve body conductor plate circuits fail, causing erratic shift behavior. Requires transmission removal, valve body replacement or rebuild, new fluid and filter. 12-16 labor hours including programming.
Estimated cost: $3,500-5,500
Transmission Oil Cooler Line Leaks
Common · medium severity
Typical onset: 70,000-130,000 mi
Symptoms: Red ATF fluid pooling under vehicle, Transmission running hot, erratic shifts, Low transmission fluid warnings on dash, Visible fluid weeping at cooler connections
Fix: Hard lines rust and corrode, or rubber sections crack at the transmission oil cooler. Requires line replacement, often cooler itself if contaminated. 4-6 hours labor depending on line routing accessibility.
Estimated cost: $800-1,800
Airmatic Suspension Compressor and Strut Failure
Common · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: Vehicle sitting low, especially after sitting overnight, Airmatic Visit Workshop message on dash, Compressor running constantly or not at all, Visible oil leaks on strut bodies
Fix: Air struts leak at seals, compressor fails from overwork. Strut replacement is 2-3 hours each corner. Compressor replacement 3-4 hours. Recommend replacing struts in pairs (front or rear) and inspecting compressor relay module.
Estimated cost: $1,200-2,500 per strut; $1,800-2,800 compressor
Transmission Mount Collapse
Occasional · medium severity
Typical onset: 80,000-140,000 mi
Symptoms: Clunking when shifting from Park to Drive/Reverse, Vibration through chassis at idle in gear, Visible sagging of transmission tail when inspected, Excessive driveline movement during acceleration
Fix: Hydraulic transmission mount fails, allowing excessive drivetrain movement. Requires proper support of transmission during replacement. 2-3 labor hours. Should inspect engine mounts simultaneously as they often fail together.
Estimated cost: $600-1,200
ABC (Active Body Control) Hydraulic System Leaks
Occasional · high severity
Typical onset: 90,000-150,000 mi
Symptoms: ABC Visit Workshop warning, vehicle drops to bump stops, Steering feels heavy or unresponsive, Green hydraulic fluid leaking under vehicle, System won't raise vehicle from lowered position
Fix: If equipped with ABC (not all S550s), hydraulic lines, pulsation dampers, and pump fail. Pump replacement 6-8 hours, struts 3-5 hours each. This system is brutally expensive; many owners convert to conventional Airmatic or coil suspension.
Estimated cost: $3,000-8,000 depending on component
Alternator Failure with Water Damage
Occasional · medium severity
Typical onset: 70,000-120,000 mi
Symptoms: Battery warning light, electrical system voltage fluctuation, No-start condition after rain or car wash, Visible water intrusion in alternator area, Multiple electrical faults stored in system
Fix: Alternator positioned low and vulnerable to water intrusion from clogged drain tubes. Replacement 3-4 hours including battery registration programming. Always clear AC drain tubes and sunroof drains during service.
Estimated cost: $1,200-2,000
Owner tips
Change oil every 5,000 miles with quality synthetic - extended intervals accelerate balance shaft wear on M273 engines
Inspect oil religiously for metal content starting at 50k miles; catching balance shaft wear early can save the engine
Transmission fluid and filter every 40,000 miles despite 'lifetime' claims - prolongs 722.9 valve body life
Clear all drain tubes (sunroof, AC, door) annually to prevent water damage to electronics and alternator
Budget $3,000-5,000 annually for repairs after 80k miles - this is not a low-maintenance platform
Only buy if under 60,000 miles with immaculate service records and a $10,000 repair fund set aside - the M273 engine is a ticking time bomb that makes this otherwise excellent luxury sedan a high-stakes gamble.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: AGM battery required; located in trunk on right side; auxiliary battery present in engine bay
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2007-2010 Mercedes-Benz S550 W221 — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
⚠️ Controlled by SAM-R; can cause no-start if faulty
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2007 Mercedes-Benz S550 W221 5.5L V8 M273 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.