The 2015 SL63 AMG with the M157 5.5L twin-turbo V8 is a high-performance GT that suffers from catastrophic engine failure due to a defective crankshaft bolt design, plus typical AMG wear items like transmission mounts and cooling system stress from the twin-turbo setup.
Symptoms: Sudden catastrophic engine noise, knocking from lower end, Metal shavings in oil, low oil pressure warning, Complete engine seizure in worst cases, May have no warning before failure
Fix: The balance shaft crankshaft bolts can back out and grenade the engine. Requires complete engine teardown at minimum, often full short block or long block replacement. 25-35 hours labor for short block swap, more if internal damage is extensive. This is a known Mercedes defect with class-action history.
Estimated cost: $18,000-35,000
Transmission Oil Cooler and Line Leaks (722.9 / MCT)
Common · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: Transmission fluid dripping from undercarriage, Burnt transmission fluid smell, Harsh shifting or slipping when fluid level drops, Red fluid puddles under vehicle
Fix: The MCT (Multi-Clutch Transmission) runs hot and the oil cooler lines crack or the cooler itself develops leaks. Requires dropping subframe or extensive undercarriage work to access. 6-10 hours labor depending on line routing and cooler location. Flush and refill required.
Estimated cost: $1,800-3,200
Engine and Transmission Mounts
Common · medium severity
Typical onset: 40,000-80,000 mi
Symptoms: Clunking on acceleration or deceleration, Excessive vibration at idle, Drivetrain shudder during gear changes, Visible separation or fluid leaking from hydraulic mounts
Fix: The M157's torque and AMG's performance tuning destroy mounts faster than standard models. Hydraulic mounts leak and rubber tears. Transmission mount is especially prone. 3-5 hours labor for engine mounts, 2-3 hours for transmission mount. Replace all simultaneously for best results.
Estimated cost: $1,200-2,400
Turbocharger Wastegate Rattle and Failure
Occasional · high severity
Typical onset: 70,000-120,000 mi
Symptoms: Rattling noise on cold start that disappears when warm, Loss of boost pressure, limp mode, Check engine light with underboost codes (P0299, P0234), Reduced power output, sluggish acceleration
Fix: Wastegate actuator arms wear or seize, causing rattle or stuck-open condition. Early stages just rattle, but eventually turbos lose boost control. Turbo replacement is the fix—remanufactured units available but OEM pricing is brutal. 12-16 hours labor for both turbos. Often one side first, then the other follows within 20k miles.
Estimated cost: $4,500-8,000
Active Body Control (ABC) Hydraulic System Leaks
Occasional · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: ABC warning light and 'vehicle rising' message, Car sagging on one corner overnight, Green hydraulic fluid leaking under vehicle, Rough ride quality, suspension feels harsh
Fix: ABC struts, lines, and valve blocks develop leaks as seals age. Diagnosis requires ABC scan tool to pinpoint which corner. Strut replacement is 4-6 hours per corner, valve block is 8-12 hours. Fluid is expensive and system must be bled properly. Full system flush adds cost.
Estimated cost: $2,000-6,000
Fuel Injector and High-Pressure Fuel Pump Issues
Occasional · medium severity
Typical onset: 80,000-130,000 mi
Symptoms: Rough idle, misfires on multiple cylinders, Hard starting especially when hot, Fuel smell in cabin or engine bay, Check engine light with lean/rich or misfire codes
Fix: Direct injection systems run high pressure and injectors clog or leak. High-pressure pump can also fail causing low rail pressure. Injectors are 6-8 hours labor for full set replacement (requires intake removal), pump is 4-5 hours. Carbon buildup on intake valves exacerbates issues—walnut blasting recommended simultaneously.
Estimated cost: $2,500-4,500
Owner tips
Check service records for crankshaft bolt recall or TSB work—Mercedes extended warranty coverage on some VINs but not all, and many owners are unaware until failure
Budget $3,000-5,000 annually for maintenance on a high-mileage example; this is a $150k+ car when new and parts pricing reflects that
ABC fluid should be flushed every 3 years or 40k miles regardless of what the manual says—preventive measure for a $15k suspension system
Use only premium fuel and change oil every 5,000 miles with MB 229.5 spec oil—turbo V8s are unforgiving of neglect
Pre-purchase inspection MUST include oil analysis and compression test to catch early signs of M157 internal issues
Buy only with comprehensive records and a pre-purchase inspection by an AMG specialist, or budget $20k+ for inevitable M157 engine work—this is a ticking time bomb wrapped in stunning performance and luxury.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: Battery located in trunk; high-performance AGM required for AMG electrical demands and start-stop system
As an Amazon Associate and Autel/ANCEL partner, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2013-2017 Mercedes-Benz SL63 AMG — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
⚠️ Memory seats with heating/ventilation/massage. Position adaptation recommended.
Intelligent Light System Control Unit (ILS)0.5 hr R&Raftermarket tool +0.2 hr▸ programming details
📍 Each headlight assembly (2 units)
🔧 Xentry or Autel
⚠️ Adaptive LED headlights (2015+). Auto-calibration via drive cycle.
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2015 Mercedes-Benz SL63 AMG 5.5L V8 BiTurbo M157 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Mechanic · 20+ years.