2001 PONTIAC AZTEK

Typical onset: 80,000-140,000 mi

Symptoms: White smoke from exhaust on cold start, Milky oil on dipstick or under oil cap, Unexplained coolant loss with no visible leaks, Rough idle and eventual misfire codes, Catastrophic bearing damage if driven after mixing starts

Fix: The Dex-Cool coolant eats the factory plastic intake gaskets, allowing coolant into the crankcase. Requires upper and lower intake gasket replacement (8-10 hours labor). If caught early, gasket job alone. If driven with contaminated oil, expect full engine rebuild with bearings, pistons, and rings—documented extensively in repair data for this platform. Many owners discover this too late and need short-block replacement.

Estimated cost: $1,200-2,200 for gaskets alone; $4,500-7,500 for engine rebuild if bearing damage occurs

Typical onset: 90,000-150,000 mi

Symptoms: Transmission fluid leaking from radiator area, Pink or red fluid in coolant overflow tank (cross-contamination), Sudden transmission slipping or failure to engage gears, Transmission overheating warnings if equipped

Fix: Factory crimp-style cooler lines corrode and rupture where they connect to the radiator. When this happens, coolant enters the transmission and destroys clutches within days. Requires immediate cooler line replacement (2-3 hours), radiator flush, and often full 4T65-E transmission rebuild or replacement because most people drive it after contamination starts. Preventive line replacement is cheap insurance.

Estimated cost: $350-600 for lines alone preventively; $2,500-4,200 for transmission rebuild after contamination

Typical onset: 100,000-160,000 mi

Symptoms: No-start condition with cranking but no fire, Intermittent stalling at highway speed, Whining noise from rear of vehicle, Fuel pressure below spec (should be 52-59 psi)

Fix: The in-tank fuel pump assembly fails, often suddenly. Requires dropping the fuel tank (3-4 hours labor). This platform saw increased fuel pump replacements, documented in repair frequency data. Replace the entire assembly, not just the pump, to avoid repeat failures.

Estimated cost: $600-900

Typical onset: 70,000-120,000 mi

Symptoms: Excessive vibration at idle in Drive, Clunking when shifting from Park to Drive, Engine rocks forward/backward during acceleration, Visible sagging of engine/trans when viewed from side

Fix: The rear transmission mount (torque strut) deteriorates and the hydraulic engine mount fails, causing harsh shifting feel and vibration. Replace both engine and transmission mounts as a set (2.5-3.5 hours). This is maintenance-level but frequently neglected, leading to accelerated driveline wear.

Estimated cost: $350-550

Symptoms: Driver or passenger seat back suddenly reclines without input, Recliner lever does not hold position, Seat back rattles or feels loose, Safety risk in sudden stops or collisions

Fix: GM issued a recall for front seat recliners that can fail and allow seatback to recline unexpectedly. Affected units may not have been repaired. Requires replacement of entire seat frame or recliner mechanism depending on which side failed (3-4 hours per seat). Verify recall completion before purchase.

Estimated cost: $0 if recall not completed (dealer covers); $500-800 if out of recall window

Typical onset: 110,000-180,000 mi

Symptoms: ABS and Traction Control warning lights constantly illuminated, No ABS function during panic stops, Speedometer intermittently drops to zero, Codes C0035, C0040 stored in ABS module

Fix: The EBCM (Electronic Brake Control Module) fails internally, often from corrosion on circuit board. Requires replacement of ABS module with programming (2-3 hours). Some units can be rebuilt by specialists, but replacement is more common in the field.

Estimated cost: $800-1,400