The 2010 Pontiac G6 is a late-generation GM mid-sizer that shares the Epsilon platform with the Malibu and Aura. While decent when running, it's plagued by catastrophic engine failures on the 2.4L and chronic transmission/cooler issues that make it a risky used buy.
2.4L Ecotec Timing Chain Failure Leading to Complete Engine Destruction
Common · high severity
Typical onset: 80,000-120,000 mi
Symptoms: Rattling noise on cold start that goes away after warmup, Check engine light with cam/crank correlation codes (P0016, P0017), Sudden catastrophic failure: pistons hit valves, metal debris through entire engine, Oil consumption between changes (early warning sign)
Fix: Timing chain stretches, guides break, engine jumps time and self-destructs. By the time you hear it, damage is often done. Used engine swap is most economical: 12-16 hours labor. Rebuild with updated tensioner/guides runs 25-35 hours but hard to justify on this platform. See this weekly in the shop.
Estimated cost: $3,500-6,500
Transmission Oil Cooler Line Corrosion and Failure
Common · high severity
Typical onset: 70,000-110,000 mi
Symptoms: Pink fluid puddle under vehicle (trans fluid mixed with coolant), Transmission slipping or delayed engagement after cooler fails, Milky/strawberry-colored transmission fluid on dipstick, Overheating transmission, burnt smell
Fix: Steel cooler lines rust through where they connect to radiator, especially in salt states. Trans fluid mixes with coolant, destroying both systems. Requires cooler line replacement (2-3 hours), often radiator too (add 3 hours), full trans fluid flush, sometimes transmission replacement if contaminated coolant got circulated. Seen dozens of these.
Estimated cost: $800-4,000
6T70 Automatic Transmission Internal Failures
Occasional · high severity
Typical onset: 90,000-140,000 mi
Symptoms: Harsh 2-3 or 3-4 shifts, especially when cold, Shuddering or slipping during acceleration, Check engine light with transmission codes (P0700 series), Delayed engagement into drive or reverse
Fix: The 6T70 six-speed has well-documented issues with 3-5-R clutch pack and wave plate failures. Aftermarket rebuild kits exist with updated parts. R&R and rebuild: 14-18 hours. Used transmission swap: 10-12 hours but gamble on same problems. Independent shops can rebuild cheaper than dealer.
Estimated cost: $2,800-4,200
3.5L/3.9L V6 Intake Manifold Gasket Leaks
Common · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: Coolant smell in cabin or under hood, Coolant loss with no visible external leaks, Rough idle or misfire when cold, White smoke from exhaust on startup
Fix: Plastic intake manifold gaskets deteriorate, leak coolant into cylinders or externally. Upper and lower manifold removal required: 4-6 hours. Must replace both upper and lower gaskets, inspect runners for warpage. V6 models only, but we see it on every high-mile example.
Estimated cost: $650-1,100
Power Steering Pressure Hose and Pump Failures
Occasional · medium severity
Typical onset: 75,000-120,000 mi
Symptoms: Whining or groaning noise when turning wheel, Heavy steering effort, especially when cold, Power steering fluid leaking from hose near pump, Burning smell from fluid on exhaust
Fix: High-pressure hose develops leaks at crimps, pump wears out prematurely. Hose replacement: 1.5-2 hours. Pump replacement: 2-3 hours. Both often needed together if fluid ran low and damaged pump. Flush system after repairs to prevent repeat failure.
Estimated cost: $400-900
EVAP Purge Valve and Vent Valve Failures
Common · low severity
Symptoms: Check engine light with P0446, P0496, P0455 codes, Fuel smell around vehicle, Difficulty fueling (pump clicks off repeatedly), Rough idle when first starting after refueling
Fix: Purge solenoid and vent valve stick open or closed, causing emissions system codes. Purge valve is easy: 0.5 hours on engine. Vent valve requires fuel tank access: 2-3 hours. Diagnosis time adds cost if shop chases smoke. Common enough we stock the parts.
Estimated cost: $200-600
Owner tips
If buying a 2.4L, verify timing chain was already replaced with updated GM parts or budget for immediate replacement
Inspect transmission cooler lines for rust at radiator junction during any service — catch it before catastrophic failure
Change transmission fluid every 50k miles regardless of 'lifetime fill' claims — these transmissions need fresh fluid
Run full synthetic oil in 2.4L engines and change every 5k max to slow timing chain stretch
Check for coolant in transmission fluid and transmission fluid in coolant at every oil change
Hard pass unless free — the 2.4L engine is a ticking time bomb and the transmission cooler design is fundamentally flawed, making even low-mileage examples expensive gambles.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: Side post terminals standard on GM vehicles
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2009-2010 Pontiac G6 — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
Radio/Entertainment System (RAD)0.7 hr R&Rrelearn only +0.2 hr▸ programming details
📍 Center stack dash, integrated radio unit
🔧 Tech 2 or aftermarket
⚠️ Theft lock code may be required; OnStar integration on equipped models
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
Consequence: A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Remedy: Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
ELECTRICAL SYSTEM:WIRING · 14V252000
2014-05-14 · EA13005
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) · 12V460000
2012-09-18
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
Consequence: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
Remedy: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Wiper blades
Sedan body style, no rear wiper. Final model year for G6.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2010 Pontiac G6 3.9L V6 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.