The 2009 Forester XT uses the EJ255 turbocharged boxer engine paired with a 4-speed automatic or 5-speed manual. Head gasket failures and turbo-related issues dominate the problem list, with transmission cooler line failures being a critical concern on automatics.
Head Gasket Failure (External Leaks)
Common · high severity
Typical onset: 80,000-130,000 mi
Symptoms: Oil seepage from cylinder heads visible around engine block, Coolant smell from engine bay, Oil residue accumulating on exhaust manifolds, Gradual coolant loss without visible external puddles
Fix: Both head gaskets require replacement; includes timing belt/water pump service while engine is apart. 12-16 labor hours. Head resurfacing typically needed, adds 2-3 hours machine shop time.
Estimated cost: $2,800-4,200
Transmission Oil Cooler Line Failure
Common · high severity
Typical onset: 70,000-110,000 mi
Symptoms: ATF pooling under vehicle front-center, Rapid transmission fluid loss, Transmission overheating warning, Pink fluid visible near radiator area
Fix: Steel cooler lines rot through where they route along subframe. Requires OEM replacement lines; aftermarket versions fail quickly. 3-4 labor hours including fluid replacement and system flush.
Estimated cost: $600-950
Turbocharger Failure / Oil Starvation
Occasional · high severity
Typical onset: 100,000-150,000 mi
Symptoms: Blue smoke on acceleration, Whistling or grinding noise from turbo, Loss of boost pressure, Check engine light with underboost codes P0035/P0236, Excessive oil consumption
Fix: Turbo bearing failure often caused by oil feed line coking or banjo bolt filter clogging. Replacement requires OEM or quality aftermarket turbo, oil feed/return line cleaning, and often leads to discovering ring land failures. 8-10 labor hours if engine internals are sound.
Estimated cost: $2,200-3,800
Piston Ring Land Failure
Occasional · high severity
Typical onset: 90,000-140,000 mi
Symptoms: Excessive oil consumption (1 quart per 1,000 miles or worse), White/blue smoke on cold start, Misfires under boost, Compression loss on one or more cylinders, Rattling noise from engine under load
Fix: EJ255 pistons crack between top ring and piston crown, especially cylinder #4. Requires engine removal and short block replacement or full rebuild with forged pistons. 20-25 labor hours minimum.
Estimated cost: $5,500-8,500
Banjo Bolt Filter Clogging (Turbo Oil Feed)
Common · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: Turbo whistle or whine increases over time, Sluggish boost response, Oil residue around turbo oil feed connection, Early-stage turbo bearing noise
Fix: Tiny filter screen in banjo bolt clogs with carbon deposits, starving turbo of oil. Preventive removal of filter screen and line cleaning during oil changes extends turbo life. 1.5 labor hours if caught early.
Estimated cost: $150-300
Transmission Mount Failure
Common · low severity
Typical onset: 70,000-120,000 mi
Symptoms: Clunking when shifting from Park to Drive, Excessive driveline vibration at idle, Visible engine/transmission movement during acceleration, Thumping over bumps from underneath
Fix: Rear transmission mount deteriorates and separates. Quick replacement job. 1.5-2 labor hours.
Estimated cost: $250-450
Fuel Filter / Fuel Pump Assembly Clogging
Occasional · medium severity
Typical onset: 100,000+ mi
Symptoms: Hesitation under acceleration, Stumbling at high RPM, Hard starting when hot, Fuel trims running extremely rich or lean, Check engine light for lean codes
Fix: In-tank fuel pump basket screen clogs; often caused by debris from deteriorating tank lining. Requires fuel tank drop and pump assembly replacement. 3-4 labor hours.
Estimated cost: $600-1,100
Owner tips
Change oil every 3,750 miles with quality synthetic — the EJ255 runs hot and oil degradation accelerates turbo and piston failures
Remove the banjo bolt filter screen from turbo oil feed line during routine maintenance to prevent turbo starvation
Inspect transmission cooler lines annually; coating with rust protection or replacement before failure saves the transmission
Monitor oil consumption closely — anything over 1 quart per 3,000 miles signals developing ring land issues
Replace timing belt, water pump, and all idler pulleys at 105,000 miles or 10 years; interference engine will destroy valves if belt fails
Buy only with comprehensive service records showing religious oil changes and proactive cooling system maintenance; budget $3,000-5,000 for likely head gasket or turbo work within first 30,000 miles of ownership.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2009 Subaru Forester XT
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester vehicles. The front seat belt assembly force-limiter may not operate correctly in the event of a crash.
Consequence: The seat belt assembly may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the seat belt assembly, if necessary, free of charge. Owner notification letters are expected to be mailed December 9, 2022. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WRJ-22.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V001000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (STI included), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators with alternate inflators, free of charge. The recall began January 7, 2020. Subaru Owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKA-20.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V002000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKB-20.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V003000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKC-20.
ELECTRICAL SYSTEM:IGNITION:SWITCH · 19V297000
2019-04-11
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester vehicles, 2008-2011 Impreza vehicles, 2008-2014 WRX vehicles, 2005-2014 Legacy vehicles, 2005-2014 Outback vehicles and 2006-2008 Tribeca vehicles equipped with a mechanical key ignition switch installed as a replacement part. The ball spring inside the switch may break, reducing the strength of the ignition switch. If this occurs, the weight on the key ring and certain road conditions could cause the ignition switch to move out of the run position to the accessory position, turning off the engine.
Consequence: The engine turning off unexpectedly can increase the risk of a crash. If a crash occurs under this condition, the air bag may not deploy, increasing the risk of injury.
Remedy: Subaru will notify owners, and dealers will inspect the ignition switch, replacing the ignition switch, if necessary, free of charge. The recall began May 10, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUF-91.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V012000
2018-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Legacy, Forester, Tribeca, WRX and Outback vehicles, and 2009-2011 Impreza vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on February 9, 2018. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKA-18.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V013000
2018-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2010 Tribeca, Impreza, Forester, WRX, Legacy, and Outback vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on February 9, 2018. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKB-18.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V014000
2018-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009 Tribeca, Impreza, Forester, WRX, Legacy, and Outback vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflators, free of charge. The recall began on February 9, 2018. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKC-18.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 17V026000
2017-01-11 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2005-2006 Baja, 2009 Forester, Legacy and Outback and 2006-2009 Impreza (including WRX and STI models) and Tribeca vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the passenger front air bag inflator, free of charge. The recall began March 6, 2017. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKB-17.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 17V014000
2017-01-10 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2005-2006 Subaru Baja, 2006-2011 Impreza (including WRX and STI models), 2006-2012 Tribeca, 2009-2012 Forester, Legacy, Outback, and 2012 WRX vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began March 6, 2017. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKA-17.
ELECTRICAL SYSTEM · 16V738000
2016-10-13
Subaru of America, Inc. (Subaru) is recalling certain model year 2007-2009 model year Legacy and Outback vehicles, 2008-2014 Impreza vehicles and 2009-2013 Forester vehicles, all equipped with turbo-charged engines. The relay that controls the secondary air injection pump may fail, causing the pump to continuously operate and overheat.
Consequence: If the air injection pump overheats, it may melt and increase the risk of a fire.
Remedy: Subaru will notify owners, and dealers will replace the secondary air injection pump relay, free of charge. The recall began December 2016. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WTM-73.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 16V358000
2016-05-25 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Legacy, Outback, 2009-2011 Legacy, Outback, Forester, 2006-2011 Impreza, Tribeca, 2003-2006 Baja, and 2006 Saab 9-2x vehicles originally sold or that have ever been registered in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A."
These vehicles may be equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began August 26, 2016. Owners may contact Subaru customer service at 1-856-488-8500. Saab owners may contact GM at 1-800-955-9007. Subaru's number for this recall is TKA-16.
SERVICE BRAKES, HYDRAULIC · 14V830000
2014-12-31
Subaru of America, Inc. (Subaru) is recalling certain model year 2008-2011 Impreza, 2008-2014 WRX and STI, and 2009-2013 Forester vehicles, currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia that were remedied under recall 14V-311 prior to December 23, 2014. The brake lines may experience brake line corrosion due to salt water splashing on the brake lines through a gap in the fuel tank protector.
Consequence: Brake fluid may leak due to the brake line corrosion and may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Remedy: Subaru will notify owners, and dealers will apply an anti-corrosion wax to the four-way joint connector area of the brake line system, free of charge. The recall began on January 27, 2015. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WQQ-52. Notes: This recall is specific to affected Forester, Impreza, WRX, and STI customers who had their car remedied under NHTSA recall no. 14V-311 prior to December 23, 2014. Subaru has determined that this remedy was inadequate due to incomplete repair instructions provided to dealers. Affected Forester, Impreza, WRX, and STI vehicles that were not repaired under NHTSA recall no. 14V-311 prior to December 23, 2014 will continue to be processed under NHTSA recall no. 14V-311. Affected vehicles not currently, or formerly, registered in the salt belt states identified in this recall are eligible for repair, at no cost to the customer, upon request.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS · 14V311000
2014-06-10
Subaru of America, Inc. (Subaru) is recalling certain model year 2005-2009 Outback and Legacy, 2008-2011 Impreza and 2008-2014 Impreza WRX/STI, and 2009-2013 Forester vehicles, currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.
Note that affected vehicles not currently, or formerly registered, in the salt belt states identified above are eligible for repair, at no cost to the customer, upon request.
Consequence: Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Remedy: Subaru will notify owners, and dealers will test the brake system by depressing the brake pedal and inspecting for brake fluid leaks. If no brake fluid seepage is observed, the affected areas will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began July 2014 and second notifications will run through November 2014. Owners may contact Subaru at 1-800-782-2783. Subaru's recall campaign number is WQK-47. Note: This recall supersedes recall 13V-110 which applied to certain 2005-2009 Legacy/Outback vehicles. Vehicles that were remedied under the previous campaign still need additional areas rust-proofed.
EXTERIOR LIGHTING · 12V602000
2012-12-26
Subaru is recalling certain model year 2010 and 2011 Legacy and Outback vehicles, certain model year 2006 through 2012 Tribeca vehicles sold before January 2012, and certain model year 2009 through 2012 Forester vehicles sold before January 2012. Up to 78,650 of these vehicles may have been equipped with accessory puddle lights that, when illuminated, brighten the area under the doors of the vehicle. A short circuit can develop when either the puddle light or connector are exposed to an electrolytic moisture source (such as road spray that has road salt in it) and it penetrates the circuit board of the puddle light or the pins of the puddle light connector(s).
Consequence: Over time, migration of the moisture into the circuit board and/or into the connector cavity, may result in a short circuit of the puddle light system. This may generate heat which may melt the plastic resulting in smoke or fire.
Remedy: Subaru will notify owners, and dealers will install an additional fused-harness, free of charge. The recall began February 19, 2013. Owners may contact Subaru at 1-800-782-2783 for more information.
SEAT BELTS:REAR/OTHER · 12V099000
2012-03-13
SUBARU IS RECALLING CERTAIN MODEL YEAR 2009-2012 FORESTER VEHICLES MANUFACTURED FROM NOVEMBER 26, 2007, THROUGH MARCH 13, 2012. THE AUTOMATIC LOCKING RETRACTOR in the SEAT BELT ASSEMBLIES LOCATED IN THE REAR CENTER SEATING OF THE AFFECTED VEHICLES DO NOT MEET LOCKABILITY REQUIREMENTS AND FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, OCCUPANT CRASH PROTECTION. SPECIFICALLY, THE ASSEMBLIES MAY NOT PERMIT PROPER INSTALLATION AND SECURE ATTACHMENT OF A CHILD RESTRAINT IN THAT SEATING POSITION.
Consequence: AN INSECURE INSTALLATION OF A CHILD RESTRAINT CAN INCREASE THE RISK OF INJURY TO A CHILD DURING A CRASH.
Remedy: SUBARU WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REAR CENTER SEAT BELT ASSEMBLY WITH A NEWLY MODIFIED AUTOMATIC LOCKING RETRACTOR, FREE OF CHARGE. AN INTERIM LETTER WAS MAILED ON MARCH 26, 2012. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783.
EQUIPMENT · 09E011000
2009-04-02
THULE, INC. IS RECALLING 2,323 OWNER-INSTALLED ROOF-MOUNTED FIT KITS, MODELS 3068 AND 3069, MANUFACTURED BETWEEN JANUARY 1, 2008 AND FEBRUARY 28, 2009 THAT ARE USED WITH THULE PODIUM FOOT PACKS, MODELS 460 AND 460R. THESE FIT KITS WERE SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE BOLT(S) USED TO SECURE THE FOOT TO THE VEHICLE WAS MANUFACTURED TO A HARDNESS THAT MAY CAUSE THE BOLT(S) TO BE BRITTLE AND POTENTIALLY BREAK UNDER STRESS.
Consequence: THIS MAY RESULT IN THE BOLT(S) SNAPPING OFF DURING USE OR WITHOUT A LOAD. THE UNSECURED RACK AND LOAD CAN THEN COME LOOSE WHILE DRIVING CREATING A POTENTIAL ROAD HAZARD, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: THULE WILL MAIL A RETRO FIT KIT ALONG WITH REPAIR INSTRUCTIONS TO OWNERS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 13, 2009. OWNERS MAY CONTACT THULE TOLL-FREE AT 1-800-238-2388.
ENGINE AND ENGINE COOLING:ENGINE · 08V460000
2008-09-11
SUBARU IS RECALLING 16,715 MY 2007-2008 LEGACY SEDANS AND WAGONS, MY 2008 IMPREZA SEDANS AND WAGONS, AND MY 2009 FORESTER VEHICLES. SOME VEHICLES MAY HAVE THE CYLINDER HEAD-SIDE OIL SUPPLY PIPE AND TURBOCHARGER-SIDE PIPE IMPROPERLY ASSEMBLED.
Consequence: VIBRATION WOULD OCCUR WHILE DRIVING AND, OVER TIME, COULD EVENTUALLY RESULT IN CRACKING THE PIPE WHICH WOULD ALLOW OIL TO LEAK. IF LEAKING OIL CONTACTS COMPONENTS OPERATING AT HIGH TEMPERATURES, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR CRACKING OR AN OIL LEAK AT THE OIL SUPPLY PIPE AT THE CYLINDER HEAD-SIDE. AN ADDITIONAL BRACKET WILL BE INSTALLED TO INCREASE RIGIDITY OF THE PIPE AND THE PIPE ASSEMBLY WILL BE REPLACED WITH A MODIFIED PART. THE RECALL BEGAN ON OCTOBER 20, 2008. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783.
Performance
Horsepower
224hp
Torque
226lb-ft
0–60 mph
6.3sec
Quarter mile
14.9sec
Top speed
130mph
Capability & size
Towing capacity
2,400lb
Payload
1,050lb
Curb weight
3,520lb
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2009 Subaru Forester XT 2.5L Turbo H4 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.