The 2009 Legacy GT with the EJ255 2.5L turbo is a capable sport sedan plagued by well-documented engine durability issues, particularly ringland failures and head gasket leaks. Transmission cooler lines and mounts also fail regularly, but the powertrain internals are the real concern.
Ringland Failure / Piston Cracking (Cylinder #4 most common)
Common · high severity
Typical onset: 60,000-120,000 mi
Symptoms: Sudden misfire on cylinder #4, flashing CEL, Loud rattling or knocking from engine, Loss of compression on one cylinder, White smoke on cold start if coolant intrusion occurs
Fix: Requires full engine teardown. Most techs recommend short block replacement over rebuilding cracked pistons — 18-24 labor hours including turbo removal, timing components, and reassembly. Forged pistons highly recommended if rebuilding to prevent recurrence.
Estimated cost: $4,500-7,500
Head Gasket Failure (External Coolant Leaks)
Common · medium severity
Typical onset: 80,000-140,000 mi
Symptoms: Coolant seepage at bottom of engine block, Slow coolant loss with no obvious leak, Slight sweet smell from engine bay, No overheating initially, just loss of fluid
Fix: External seepage between block and head. Requires pulling engine due to horizontal layout — 12-16 hours labor. Must resurface heads, replace timing components and all gaskets while apart. OEM multi-layer steel gaskets mandatory.
Estimated cost: $2,500-4,000
Transmission Oil Cooler Line Failure
Common · high severity
Typical onset: 70,000-110,000 mi
Symptoms: ATF puddle under car, typically passenger side, Sudden transmission fluid loss, Slipping or delayed engagement if driven after leak starts, Corroded hard lines or cracked rubber connections at radiator
Fix: Steel lines rust through where they pass the subframe or connect to rubber hoses. Replace all cooler lines as a set, not just the leaking section — 2-3 hours. Transmission damage possible if driven low on fluid.
Estimated cost: $400-700
Transmission Mount Collapse (Rear/Pitch Mount)
Common · low severity
Typical onset: 60,000-100,000 mi
Symptoms: Clunk on acceleration or deceleration, Excessive drivetrain movement felt in cabin, Vibration at idle in Drive, Visible tearing or separation of rubber on mount
Fix: Rear transmission mount deteriorates from heat and load. Accessible from underneath — 1.5-2 hours. Use OEM or quality aftermarket (Torque Solution, Perrin). Cheap mounts fail in under 20k miles.
Estimated cost: $250-400
Turbocharger Wastegate Rattle / Bearing Failure
Occasional · medium severity
Typical onset: 90,000-150,000 mi
Symptoms: Rattling from engine bay on cold start that goes away when warm, Whining or whistling under boost, Loss of boost pressure, limp mode, Blue smoke on deceleration if seals fail
Fix: IHI VF40 turbos develop wastegate actuator rod play or bearing wear. Rebuild or replacement required — 6-8 hours with manifold removal. Upgraded turbos (VF52, aftermarket) common at this point.
Estimated cost: $1,200-2,500
Banjo Bolt Filter Clogging (Turbo Oil Feed)
Occasional · high severity
Symptoms: Turbo failure with low mileage or after oil change, Whining turbo, blue smoke, No obvious cause for bearing failure
Fix: Tiny filter screens in banjo bolts at turbo oil feed line clog with debris, starving turbo bearings. Many techs remove screens entirely during any turbo service. Check/replace during oil changes if accessible — 0.5 hours as preventive measure.
Estimated cost: $50-150
Timing Belt & Water Pump Service Neglect Leading to Interference Damage
Occasional · high severity
Typical onset: 105,000+ mi
Symptoms: Sudden no-start, cranks but won't fire, Metallic clattering on startup if belt skipped teeth, History shows no timing belt service at 105k interval
Fix: EJ255 is interference engine. Skipped belt service or failed water pump seizes and breaks belt = bent valves minimum, often piston damage. Full head rebuild or engine replacement — 20+ hours. Timing belt service is 5-6 hours and cheap insurance.
Estimated cost: $5,000-8,000
Owner tips
Change oil every 3,750 miles with quality synthetic — these motors are oil-sensitive andrun hot
Do timing belt, water pump, and all idlers/tensioners at 105k without exception
Inspect transmission cooler lines annually for rust, especially in salt states
Avoid aggressive tuning or boost increases without forged internals — ringlands crack easily
Check banjo bolt screens during oil changes; many techs remove them permanently
Only buy if you can afford a spare $5k for inevitable engine work or find one with documented short block replacement — otherwise it's a ticking time bomb.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2009 Subaru Legacy GT
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V001000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (STI included), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators with alternate inflators, free of charge. The recall began January 7, 2020. Subaru Owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKA-20.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V002000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKB-20.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V003000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKC-20.
ELECTRICAL SYSTEM:IGNITION:SWITCH · 19V297000
2019-04-11
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester vehicles, 2008-2011 Impreza vehicles, 2008-2014 WRX vehicles, 2005-2014 Legacy vehicles, 2005-2014 Outback vehicles and 2006-2008 Tribeca vehicles equipped with a mechanical key ignition switch installed as a replacement part. The ball spring inside the switch may break, reducing the strength of the ignition switch. If this occurs, the weight on the key ring and certain road conditions could cause the ignition switch to move out of the run position to the accessory position, turning off the engine.
Consequence: The engine turning off unexpectedly can increase the risk of a crash. If a crash occurs under this condition, the air bag may not deploy, increasing the risk of injury.
Remedy: Subaru will notify owners, and dealers will inspect the ignition switch, replacing the ignition switch, if necessary, free of charge. The recall began May 10, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUF-91.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V012000
2018-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Legacy, Forester, Tribeca, WRX and Outback vehicles, and 2009-2011 Impreza vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on February 9, 2018. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKA-18.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V013000
2018-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2010 Tribeca, Impreza, Forester, WRX, Legacy, and Outback vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on February 9, 2018. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKB-18.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V014000
2018-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009 Tribeca, Impreza, Forester, WRX, Legacy, and Outback vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflators, free of charge. The recall began on February 9, 2018. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKC-18.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 17V026000
2017-01-11 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2005-2006 Baja, 2009 Forester, Legacy and Outback and 2006-2009 Impreza (including WRX and STI models) and Tribeca vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the passenger front air bag inflator, free of charge. The recall began March 6, 2017. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKB-17.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 17V014000
2017-01-10 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2005-2006 Subaru Baja, 2006-2011 Impreza (including WRX and STI models), 2006-2012 Tribeca, 2009-2012 Forester, Legacy, Outback, and 2012 WRX vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began March 6, 2017. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKA-17.
ELECTRICAL SYSTEM · 16V738000
2016-10-13
Subaru of America, Inc. (Subaru) is recalling certain model year 2007-2009 model year Legacy and Outback vehicles, 2008-2014 Impreza vehicles and 2009-2013 Forester vehicles, all equipped with turbo-charged engines. The relay that controls the secondary air injection pump may fail, causing the pump to continuously operate and overheat.
Consequence: If the air injection pump overheats, it may melt and increase the risk of a fire.
Remedy: Subaru will notify owners, and dealers will replace the secondary air injection pump relay, free of charge. The recall began December 2016. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WTM-73.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 16V358000
2016-05-25 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Legacy, Outback, 2009-2011 Legacy, Outback, Forester, 2006-2011 Impreza, Tribeca, 2003-2006 Baja, and 2006 Saab 9-2x vehicles originally sold or that have ever been registered in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A."
These vehicles may be equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began August 26, 2016. Owners may contact Subaru customer service at 1-856-488-8500. Saab owners may contact GM at 1-800-955-9007. Subaru's number for this recall is TKA-16.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS · 14V311000
2014-06-10
Subaru of America, Inc. (Subaru) is recalling certain model year 2005-2009 Outback and Legacy, 2008-2011 Impreza and 2008-2014 Impreza WRX/STI, and 2009-2013 Forester vehicles, currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.
Note that affected vehicles not currently, or formerly registered, in the salt belt states identified above are eligible for repair, at no cost to the customer, upon request.
Consequence: Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Remedy: Subaru will notify owners, and dealers will test the brake system by depressing the brake pedal and inspecting for brake fluid leaks. If no brake fluid seepage is observed, the affected areas will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began July 2014 and second notifications will run through November 2014. Owners may contact Subaru at 1-800-782-2783. Subaru's recall campaign number is WQK-47. Note: This recall supersedes recall 13V-110 which applied to certain 2005-2009 Legacy/Outback vehicles. Vehicles that were remedied under the previous campaign still need additional areas rust-proofed.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS · 13V110000
2013-03-27
Subaru is recalling certain model year 2005-2009 Outback and Legacy vehicles manufactured from December 2003, through April 2009 and currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.
Consequence: Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Remedy: Subaru will notify owners, and dealers will inspect the vehicles. If no brake fluid seepage is observed, the affected area will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began on May 30, 2013. Owners may contact Subaru at 1-800-782-2783. Subaru's recall campaign number is WQG-43.
Performance
Horsepower
243hp
Torque
241lb-ft
0–60 mph
6.1sec
Quarter mile
14.6sec
Top speed
130mph
Capability & size
Curb weight
3,615lb
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2009 Subaru Legacy GT 2.5L Turbo H4 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.