The 2010 WRX STI with the EJ257 is a high-performance platform known for bulletproof drivetrain components but notorious for engine fragility under boost, especially ringland failure and head gasket issues. Modified cars are ticking time bombs; stock examples can be reliable if meticulously maintained.
Ringland Failure (Piston #4)
Common · high severity
Typical onset: 60,000-100,000 mi
Symptoms: Misfires on cylinder 4, Loss of compression, Metal shavings in oil, Rough idle and reduced power, Check engine light with P0304 code
Fix: Full engine rebuild required — shortblock replacement minimum, often paired with cylinder head work. Budget 25-35 hours labor for proper rebuild with machine work. Higher risk on modified cars, aggressive tuning, or detonation history. OEM pistons are weak; most shops upgrade to forged aftermarket during rebuild.
Estimated cost: $5,000-9,000
Cylinder Head Gasket Failure
Common · high severity
Typical onset: 80,000-120,000 mi
Symptoms: External oil weeping from head mating surface, Coolant mixing with oil (milky dipstick), Overheating under load, White smoke from exhaust, Bubbles in coolant reservoir
Fix: Requires heads-off job with resurfacing. Plan 18-22 hours labor. Both heads should be pulled, inspected for warping, and machined flat. Replace head bolts (TTY), timing components while you're in there. Multi-layer steel (MLS) gaskets are upgrade over OEM composite.
Estimated cost: $2,500-4,200
Timing Belt and Component Wear
Occasional · high severity
Typical onset: 90,000-105,000 mi
Symptoms: No symptoms until failure, Occasional squealing on cold start if tensioner bearing failing, Metallic rattling from timing cover area
Fix: Interference engine — belt failure means bent valves and major damage. Service interval is 105k but do it at 90k on a 2010. Replace belt, tensioner, idlers, water pump, and cam/crank seals as a kit. 6-8 hours labor. Non-negotiable maintenance.
Estimated cost: $800-1,400
Transmission Mount Failure
Common · medium severity
Typical onset: 70,000-110,000 mi
Symptoms: Excessive driveline clunk on shifts, Vibration in cabin at idle, Shifter slop or wandering in gear, Transmission visibly sagging on inspection
Fix: Rear transmission crossmember mount tears or crushes from hard launches and aggressive driving. Replacement is straightforward — drop exhaust, support trans, swap mount. 2-3 hours labor. Aftermarket solid mounts reduce slop but increase NVH.
Estimated cost: $250-500
Turbocharger Wastegate Rattle and Failure
Occasional · medium severity
Typical onset: 80,000-130,000 mi
Symptoms: Rattling noise from engine bay on cold start (wastegate actuator rod), Overboost or underboost codes, Loss of boost pressure, Smoke from exhaust if turbine failed
Fix: IHI VF52 turbo suffers from wastegate actuator bracket cracking and shaft play. Rattling alone is cosmetic but indicates wear. Boost control issues require turbo replacement or rebuild. 8-10 hours labor due to top-mount location and coolant lines. Upgrade opportunity to VF48 or aftermarket.
Estimated cost: $1,800-3,200
Banjo Bolt Fuel Filter Clogging (Recall-Adjacent)
Occasional · high severity
Symptoms: Fuel starvation under hard acceleration or cornering, Lean misfire codes, Sudden loss of power, Hard starting when hot
Fix: Tiny mesh screens in banjo bolts feeding fuel rails clog with debris, starving injectors. Related to brake line recall design philosophy — small filters, big consequences. Replace banjo bolt filters and main fuel filter. 1-2 hours labor. Check after any fuel pump or tank work.
Estimated cost: $150-350
Front Wheel Bearing Failure
Occasional · medium severity
Typical onset: 70,000-100,000 mi
Symptoms: Grinding or humming noise that increases with speed, Vibration through steering wheel, ABS/VDC warning lights if sensor damaged, Wheel play when jacked up
Fix: AWD and aggressive cornering loads accelerate wear. Hub assemblies are replaced as units. Pressed bearings are available but most shops swap the hub. 2-3 hours per side labor. Do in pairs if one fails — the other is close behind.
Estimated cost: $400-700
Owner tips
Verify complete service history and avoid ANY car with aftermarket tune or mods unless you're budgeting for a rebuild
Change oil every 3,000-4,000 miles with quality synthetic — EJ257 is oil-starved in #4 cylinder by design
Replace timing belt at 90k, not 105k, and replace water pump at same time
Inspect banjo bolt filters annually and replace fuel filter every 30k, especially after any fuel system work
PPI must include compression and leakdown test — anything under 140 psi or more than 10% variance between cylinders is a red flag
Buy only unmolested, obsessively-maintained examples with records — budget $3k-5k reserve for inevitable engine work, but the chassis and drivetrain will outlast the motor every time.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Be the first to unlock repairs for the 2010 Subaru WRX STI
Procedures haven't been generated for this vehicle yet. Become the founding sponsor and we'll generate expert-grade, step-by-step repair walkthroughs for every common job on it — free for every mechanic and DIYer who looks it up after, forever.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V001000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (STI included), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators with alternate inflators, free of charge. The recall began January 7, 2020. Subaru Owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKA-20.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V002000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKB-20.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 20V003000
2020-01-02 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKC-20.
ELECTRICAL SYSTEM:IGNITION:SWITCH · 19V297000
2019-04-11
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester vehicles, 2008-2011 Impreza vehicles, 2008-2014 WRX vehicles, 2005-2014 Legacy vehicles, 2005-2014 Outback vehicles and 2006-2008 Tribeca vehicles equipped with a mechanical key ignition switch installed as a replacement part. The ball spring inside the switch may break, reducing the strength of the ignition switch. If this occurs, the weight on the key ring and certain road conditions could cause the ignition switch to move out of the run position to the accessory position, turning off the engine.
Consequence: The engine turning off unexpectedly can increase the risk of a crash. If a crash occurs under this condition, the air bag may not deploy, increasing the risk of injury.
Remedy: Subaru will notify owners, and dealers will inspect the ignition switch, replacing the ignition switch, if necessary, free of charge. The recall began May 10, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUF-91.
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH · 19V149000
2019-02-28
Subaru of America, Inc. (Subaru) is recalling certain 2014-2016 Forester, 2008-2016 Impreza sedans, 2012-2016 Impreza station wagons, 2008-2014 WRX sedans (including STI), and 2013-2017 Crosstrek vehicles. Exposure to certain contaminants may cause the brake light switch to malfunction, preventing the brake lights from illuminating and also preventing keyless ignition vehicles from starting and CVT/automatic transmissions from being able to be shifted out of Park.
Consequence: Brake lights that do not illuminate properly will not alert other drivers that the vehicle is slowing or stopping, increasing the risk of crash.
Remedy: Subaru will notify owners, and dealers will replace the brake light switch, free of charge. The recall began April 15, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUE-90.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 19V007000
2019-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2010-2013 Forester, 2010-2014 Tribeca, WRX, Outback, Legacy, and 2010-2011 Impreza vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru has notified owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began January 25, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is TKA-19.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 19V008000
2019-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2010-2014 Tribeca, WRX, Outback, and Legacy vehicles, 2010-2011 Impreza vehicles and 2010-2013 Forester vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru is notifying owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began January 25, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is TKB-19.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 19V009000
2019-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2010-2014 Tribeca, WRX, Legacy and Outback vehicles, 2010-2011 Impreza vehicles and 2010-2013 Forester vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru is notifying owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on January 25, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is TKC-19.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V012000
2018-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Legacy, Forester, Tribeca, WRX and Outback vehicles, and 2009-2011 Impreza vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on February 9, 2018. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKA-18.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE · 18V013000
2018-01-09 · EA15001
Subaru of America, Inc. (Subaru) is recalling certain 2009-2010 Tribeca, Impreza, Forester, WRX, Legacy, and Outback vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia.
These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.
Remedy: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on February 9, 2018. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKB-18.
SERVICE BRAKES, HYDRAULIC · 14V830000
2014-12-31
Subaru of America, Inc. (Subaru) is recalling certain model year 2008-2011 Impreza, 2008-2014 WRX and STI, and 2009-2013 Forester vehicles, currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia that were remedied under recall 14V-311 prior to December 23, 2014. The brake lines may experience brake line corrosion due to salt water splashing on the brake lines through a gap in the fuel tank protector.
Consequence: Brake fluid may leak due to the brake line corrosion and may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Remedy: Subaru will notify owners, and dealers will apply an anti-corrosion wax to the four-way joint connector area of the brake line system, free of charge. The recall began on January 27, 2015. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WQQ-52. Notes: This recall is specific to affected Forester, Impreza, WRX, and STI customers who had their car remedied under NHTSA recall no. 14V-311 prior to December 23, 2014. Subaru has determined that this remedy was inadequate due to incomplete repair instructions provided to dealers. Affected Forester, Impreza, WRX, and STI vehicles that were not repaired under NHTSA recall no. 14V-311 prior to December 23, 2014 will continue to be processed under NHTSA recall no. 14V-311. Affected vehicles not currently, or formerly, registered in the salt belt states identified in this recall are eligible for repair, at no cost to the customer, upon request.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS · 14V311000
2014-06-10
Subaru of America, Inc. (Subaru) is recalling certain model year 2005-2009 Outback and Legacy, 2008-2011 Impreza and 2008-2014 Impreza WRX/STI, and 2009-2013 Forester vehicles, currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.
Note that affected vehicles not currently, or formerly registered, in the salt belt states identified above are eligible for repair, at no cost to the customer, upon request.
Consequence: Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Remedy: Subaru will notify owners, and dealers will test the brake system by depressing the brake pedal and inspecting for brake fluid leaks. If no brake fluid seepage is observed, the affected areas will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began July 2014 and second notifications will run through November 2014. Owners may contact Subaru at 1-800-782-2783. Subaru's recall campaign number is WQK-47. Note: This recall supersedes recall 13V-110 which applied to certain 2005-2009 Legacy/Outback vehicles. Vehicles that were remedied under the previous campaign still need additional areas rust-proofed.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.