The 2020 Camry is generally reliable, but the 2.5L four-cylinder (A25A-FKS engine) has a serious oil consumption defect affecting 2018-2021 models that can lead to catastrophic engine failure. Hybrid models largely avoid this issue.
Symptoms: Low oil warning light with no visible leaks, Burning 1+ quart per 1,000 miles, Check engine light with misfire codes, Knocking/ticking from engine as damage progresses, Catastrophic engine seizure if oil runs critically low
Fix: Root cause is defective piston rings allowing oil into combustion chambers. Toyota's fix involves complete engine rebuild with updated pistons and rings—12-16 labor hours. Some owners get goodwill coverage outside warranty, many don't. Engine replacement runs 18-22 hours if internals are damaged.
Estimated cost: $6,500-12,000
Fuel Pump Failure (Recall 20V-490)
Occasional · high severity
Symptoms: Engine stalling at any speed without warning, No-start condition even with fuel in tank, Rough idle or hesitation under acceleration, Check engine light with fuel pressure codes
Fix: Denso low-pressure fuel pump impeller can crack and fail. Covered under recall—Toyota replaces pump assembly free of charge. Takes 2-3 hours. If you're buying used, verify recall was completed via VIN lookup.
Estimated cost: $0 (recall) / $800-1,200 if out-of-pocket
Transmission Oil Cooler Line Leaks
Occasional · medium severity
Typical onset: 50,000-90,000 mi
Symptoms: Pink/red fluid puddle under vehicle (front-center), Transmission temperature warning light, Burnt smell from transmission area, Slipping or delayed shifts if fluid level drops significantly
Fix: Cooler line fittings at radiator or inline cooler develop leaks from corrosion or vibration wear. Replace lines and flush/refill ATF—3-4 hours. Not a design flaw but age/environment accelerates it.
Estimated cost: $450-750
Transmission Mount Deterioration
Common · low severity
Typical onset: 60,000-100,000 mi
Symptoms: Clunking when shifting from Park to Drive/Reverse, Excessive vibration at idle in Drive, Engine 'rocks' visibly when accelerating hard, Thud when letting off throttle
Fix: Hydraulic transmission mount rubber separates or fluid leaks out. Common on all Camrys with this 8-speed auto. Replace mount—1.5-2 hours. OEM part strongly recommended over aftermarket.
Estimated cost: $280-450
Occupant Classification System Sensor Fault (Recall 21V-872)
Rare · medium severity
Symptoms: Passenger airbag light stays off with adult in seat, Airbag warning light illuminated on dash, Intermittent passenger airbag status changes
Fix: Software issue causes seat sensor to misclassify occupant, potentially disabling airbag. Dealer reflashes ECU—0.5 hours. Covered under recall, verify completion before purchase.
Estimated cost: $0 (recall)
Infotainment System Freezing/Rebooting
Occasional · low severity
Symptoms: Black screen on startup requiring multiple ignition cycles, Backup camera fails to display, Bluetooth disconnects randomly, System reboots while driving
Fix: Entune 3.0 software bugs or failing head unit. Try software update first (dealer or DIY via USB)—0.5 hours. If hardware failed, head unit replacement is 2-3 hours but expensive.
Estimated cost: $150-2,200
Owner tips
Check oil level every 500-1,000 miles on 2.5L non-hybrid—catch consumption early before engine damage occurs
Run VIN through Toyota's recall lookup before buying used; fuel pump and airbag sensor recalls are critical
Keep transmission fluid changes on schedule (60k intervals)—helps cooler lines and mount longevity
If buying a 2.5L four-cylinder with over 50k miles, ask for oil consumption test documentation or walk away
Hybrid models are a strong buy; non-hybrid 2.5L is a gamble—only consider with documented low oil consumption or after engine rebuild with updated parts.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: Located in trunk; hybrid auxiliary battery for 12V systems; hybrids use smaller 12V battery due to hybrid system support
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2018-2023 Toyota Camry — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
📍 Integrated into transmission valve body assembly, under vehicle
🔧 Toyota Techstream with TIS subscription
⚠️ Requires transmission removal or pan drop. VIN registration and adaptive learning reset required. 8-speed transmissions (2018-2019 V6) have external TCM on transmission case.
Electric Power Steering Control Module (EPS ECU)2.5 hr R&Rdealer / factory tool +0.5 hr▸ programming details
📍 Integrated into steering column assembly, under lower dashboard
📍 Engine compartment, driver side near strut tower
🔧 Toyota Techstream with TIS subscription
⚠️ Integrated with VSC/traction control. Brake bleeding required after replacement. VIN registration and yaw rate sensor calibration required.
Air Conditioning Amplifier / HVAC Control Module (A/C AMP)1.8 hr R&Raftermarket tool +0.2 hr▸ programming details
📍 Behind center dashboard, above center console
🔧 Autel, Launch, or Techstream
⚠️ Dual-zone systems have more complex configuration. Basic initialization can be done with aftermarket tools.
Body Control Module / Multiplex Network Body ECU (BCM)1.5 hr R&Rdealer / factory tool +1.0 hr▸ programming details
📍 Behind lower left dashboard trim, above driver kick panel
🔧 Toyota Techstream with TIS subscription
⚠️ Controls lighting, wipers, power windows, door locks. Requires VIN registration and configuration of all body options. Smart key registration required.
⚠️ Part of Toyota Safety Sense (TSS). Requires precise aiming/calibration after replacement or front-end collision. VIN registration required.
Data Communication Module / Telematics Control Unit (DCM)1.5 hr R&Rdealer / factory tool +0.5 hr▸ programming details
📍 Behind headliner, above rearview mirror area, or behind dashboard
🔧 Toyota Techstream with TIS subscription
⚠️ Safety Connect / Service Connect system. Requires activation with Toyota. VIN and subscription registration required.
Engine Control Module / Powertrain Control Module (ECM/PCM)1.2 hr R&Rdealer / factory tool +0.8 hr▸ programming details
📍 Engine compartment, driver side firewall area, mounted to bulkhead
🔧 Toyota Techstream with TIS subscription
⚠️ VIN registration, immobilizer pairing, and throttle relearn required. Hybrid models have integrated HV system communication that must be initialized.
Adaptive Front Lighting System ECU / AFS ECU (AFS ECU)1.2 hr R&Raftermarket tool +0.3 hr▸ programming details
📍 Integrated into headlight assembly, both sides
🔧 Autel, Launch, or Techstream
⚠️ Optional on XLE/XSE. Auto-leveling and cornering lamp control. Headlight aiming required after replacement.
📍 Center console area, under center floor carpet between front seats
🔧 Toyota Techstream with TIS subscription
⚠️ Crash data must be cleared. VIN registration required. Occupant classification system calibration required.
Pre-Collision Camera / Forward Recognition Camera (FR CAMERA)1.0 hr R&Rdealer / factory tool +0.8 hr▸ programming details
📍 Behind windshield, integrated into rearview mirror assembly
🔧 Toyota Techstream with TIS subscription
⚠️ Part of Toyota Safety Sense (TSS). Lane departure, road sign recognition. Requires windshield calibration and aiming after replacement. Windshield replacement requires recalibration.
⚠️ Mileage programming requires dealer access and legal documentation. VIN registration required. TFT display models (XLE/XSE) have different part numbers than analog.
⚠️ Sensor calibration required after replacement. Optional equipment on XLE/XSE trims.
Power Seat Control Module (SEAT ECU)0.8 hr R&Rno coding
📍 Under driver seat, mounted to seat frame
⚠️ Memory seats on XLE/XSE. Typically plug-and-play. Memory relearn done through user interface.
Power Window Master Switch / Door Control Module (DOOR SW)0.5 hr R&Rrelearn only +0.1 hr▸ programming details
📍 Driver door, integrated into master switch assembly
🔧 Manual initialization procedure
⚠️ Auto up/down window relearn required (manual procedure, no scan tool needed).
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION · 23V865000
2023-12-20
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.
Consequence: An air bag that does not deploy during a crash increases the risk of injury.
Remedy: Dealers will inspect and replace the sensor as necessary, free of charge. Interim letters notifying owners of the safety risk were mailed in February 2024. Some final remedy owner letters were mailed October 31, 2024. Letters will continue to be mailed in phases through January 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB15/23TA15 Lexus 23LB03/23LA03.
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
ENGINE AND ENGINE COOLING · 20V064000
2020-02-06
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2020 Toyota Camry 2.5L I4 Hybrid and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.