The 2023 S90 Recharge pairs Volvo's 2.0L turbo-hybrid with an 8-speed auto and electric motor—still too new for widespread long-term failures, but early reports and shared-platform issues (SPA architecture) point to hybrid system electronics, cooling integration concerns, and some inherited 2.0L four-cylinder weaknesses under high boost.
Transmission Oil Cooler Failure / Leaks
Occasional · medium severity
Typical onset: 40,000-70,000 mi
Symptoms: Transmission fluid leaking near cooler lines or radiator area, Transmission running hot or sluggish shifts, Pink fluid spots under vehicle
Fix: Replace transmission oil cooler and lines, flush contaminated coolant if crossover occurred. About 3-4 hours labor including flush and refill of both systems.
Estimated cost: $800-1,400
Hybrid Battery Cooling System Issues
Occasional · high severity
Symptoms: Hybrid system warning lights or reduced power mode, Battery temperature fault codes, Coolant loss with no visible external leak
Fix: Diagnose coolant routing to high-voltage battery pack, replace coolant pump or battery cooling plate seals. Can require battery pack removal in severe cases—6-10 hours labor depending on access.
Estimated cost: $1,500-3,800
Piston Ring / Cylinder Bore Wear (High-Mileage or Abused Units)
Rare · high severity
Typical onset: 80,000-120,000 mi
Symptoms: Excessive oil consumption (1 qt per 1,000 miles or worse), Blue smoke on startup or under load, Loss of compression, misfires on multiple cylinders
Fix: Engine rebuild or short-block replacement required—piston rings, honing or re-boring cylinders, new pistons if scoring present. 18-24 hours labor for proper teardown, machine work, and reassembly.
Estimated cost: $5,500-9,000
Fuel System / Fuel Filter Contamination
Occasional · medium severity
Symptoms: Hard starting, long crank times, Rough idle or hesitation under acceleration, Check engine light with fuel pressure codes
Fix: Replace in-tank fuel filter and inspect pump strainer for debris. Sometimes requires dropping fuel tank. 2-3 hours labor, more if pump is also suspect.
Estimated cost: $400-900
Transmission Mount Failure
Common · low severity
Typical onset: 50,000-80,000 mi
Symptoms: Clunking on takeoff or during shifts, Vibration at idle in Drive, Excessive driveline movement visible under throttle
Fix: Replace rear or side transmission mount. Straightforward but requires supporting trans/subframe. 1.5-2 hours labor.
Estimated cost: $350-650
Crankshaft / Main Bearing Failures (Rare, Catastrophic)
Rare · high severity
Typical onset: 60,000-100,000 mi
Symptoms: Knocking noise from lower engine, rpm-dependent, Oil pressure warning at idle, Metal shavings in oil, sudden loss of power
Fix: Crankshaft replacement requires full engine teardown, line-boring check, new bearings, possibly block replacement if journals damaged. 20-28 hours labor total.
Estimated cost: $7,000-12,000
Owner tips
Use Volvo-spec 0W-20 full synthetic and change every 7,500 miles—this turbo four runs hot and oil quality is critical to piston ring longevity.
Monitor hybrid battery coolant level and quality; pink discoloration or low level can signal early cooling-system trouble.
Avoid repeated hard launches or extended low-speed EV mode in extreme heat—stresses both the hybrid battery cooling and transmission oil cooler.
Keep an eye on oil consumption after 50k miles; if burning oil early, address it before ring scoring turns into a full rebuild.
Too new to fully judge long-term reliability, but shared 2.0L turbo and hybrid complexity mean higher stakes if something breaks—buy with comprehensive warranty or budget for hybrid electronics and potential engine work.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: AGM battery required for hybrid system; located in trunk
As an Amazon Associate and Autel/ANCEL partner, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2020-2026 Volvo S90 Recharge — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
📍 Under front seats (driver and passenger each have own module)
🔧 Autel MaxiSys or VIDA
⚠️ Power, heating, ventilation, massage; memory function may need VIDA configuration
Active High Beam Control Module (AHB)0.5 hr R&Rdealer / factory tool +0.3 hr▸ programming details
📍 Behind rearview mirror or integrated in camera module
🔧 Volvo VIDA + MVCI
⚠️ Pixel LED headlights on 2021+ models; camera calibration required
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 24, 2026. Owners may contact Volvo Car’s customer service at 1-800-458-1552. Volvo Car's number for this recall is R10333. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 16, 2026. This recall replaces previous NHTSA recall number 25V282. Vehicles previously repaired under recall 25V282 will need to have the new remedy performed.
BACK OVER PREVENTION:SOFTWARE · 25V282000
2025-05-08
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10320.
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM) · 22V793000
2022-10-20
Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
Consequence: The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.
Remedy: Dealers will update the ECM software, free of charge. Owner notification letters are expected to be mailed December 8, 2022. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10198.
Performance
Horsepower
455hp
Torque
523lb-ft
0–60 mph
4.7sec
Quarter mile
13.2sec
Top speed
112mph
Capability & size
Curb weight
4,740lb
Wiper blades
Sedan body style, no rear wiper. S90 Recharge uses same wiper setup as standard S90 second generation.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2023 Volvo S90 Recharge 2.0L Turbo I4 Hybrid and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Mechanic · 20+ years.