Maintenance Schedule 2026 Ford F-550 · 7.3L V8 Godzilla
Normal Service Severe Service
The 2026 Ford F-550 with the 7.3L Godzilla V8 follows Ford's heavy-duty truck maintenance schedule with conservative service intervals appropriate for its commercial-duty classification and pushrod V8 architecture.
💡 Tap any service to log completion + findings to your garage, or jump to a how-to.
⚙️ Engine
Engine oil and filter
5,000 mi / 6 mo
OLP recommends 5,000 mi even when manufacturer claims longer — extended-interval programs shorten engine life. Ford specifies 5W-20 or 5W-30 synthetic blend.
+ Log completion · How-to →
Coolant hoses and clamps inspection
20,000 mi / 24 mo
+ Log completion · How-to →
Engine air filter
30,000 mi
Inspect at every oil change; replace when dirty or at interval
+ Log completion · How-to →
More frequent replacement recommended for heavy-duty use or poor fuel quality
+ Log completion · How-to →
7.3L uses conventional spark plugs with long-life design
+ Log completion · How-to →
Accessory drive belt
100,000 mi / 120 mo
Inspect annually; replace at interval or if damaged
+ Log completion · How-to →
+ Log completion · How-to →
🔩 Drivetrain
Driveshaft and U-joint inspection
10,000 mi / 12 mo
Lubricate if equipped with grease fittings
+ Log completion · How-to →
Automatic transmission fluid and filter
50,000 mi
TorqShift 10-speed transmission; Ford specifies normal-duty interval at 50K for commercial trucks despite lifetime claim for light-duty
+ Log completion · How-to →
Rear differential fluid
50,000 mi
Use Motorcraft SAE 75W-140 Synthetic Rear Axle Lubricant or equivalent meeting Ford spec
+ Log completion · How-to →
Transfer case fluid (4WD)
50,000 mi
4WD models only
+ Log completion · How-to →
Wheel bearing inspection and lubrication
50,000 mi
Critical for commercial-duty trucks; repack or replace as needed
+ Log completion · How-to →
🛞 Brakes
Brake system inspection
10,000 mi / 12 mo
Inspect pads, rotors, calipers, lines, and parking brake
+ Log completion · How-to →
DOT 3 brake fluid; critical for maintaining braking performance
+ Log completion · How-to →
💧 Fluids
Engine coolant
100,000 mi / 120 mo
Yellow-colored Motorcraft Premium Gold coolant; then every 50,000 mi or 60 months
+ Log completion · How-to →
🛞 Tires
+ Log completion · How-to →
Four-wheel alignment check
20,000 mi
Or whenever uneven tire wear is observed
+ Log completion · How-to →
🔍 Inspection
Suspension and steering inspection
10,000 mi / 12 mo
Check ball joints, tie rod ends, bushings, and shock absorbers
+ Log completion · How-to →
Body and chassis lubrication
10,000 mi
Lubricate all grease fittings on steering linkage, ball joints, and driveline components
+ Log completion · How-to →
⚡ Electrical
Battery and charging system inspection
20,000 mi / 12 mo
Clean terminals and check alternator output
+ Log completion · How-to →
💨 Exhaust
Exhaust system inspection
10,000 mi / 12 mo
+ Log completion · How-to →
❄️ HVAC
Cabin air filter
20,000 mi
+ Log completion · How-to →
About this schedule: AI-generated to match the manufacturer's published recommendations for this exact engine. Severe-service intervals apply if you frequently make short trips, drive in dusty conditions, tow, or deal with extreme heat or cold. Always consult your owner's manual for warranty-required services.