The 2019 Ioniq Electric is one of the more reliable EVs on the market, but it's not immune to electric drivetrain issues. The onboard charging module and 12V battery system are the main trouble spots, while the simplicity of the single-speed transmission means fewer moving parts to fail compared to hybrids.
Onboard Charging Module (OBCM) Failure
Occasional · high severity
Typical onset: 40,000-80,000 mi
Symptoms: Vehicle won't charge from Level 1 or Level 2 EVSE, Charging error messages on dashboard, DC fast charging may still work while AC charging fails, Check EV system warning light
Fix: OBCM is integrated into the high-voltage system and requires disconnecting the traction battery. This is a dealer-level job due to HV safety protocols. Recall 22V-749 covers some VINs but not all failures qualify. 3-5 hours labor including HV lockout/tagout procedures.
Estimated cost: $1,800-3,200
12V Auxiliary Battery Premature Failure
Common · high severity
Typical onset: 30,000-60,000 mi
Symptoms: Vehicle won't enter Ready mode even with high-voltage battery charged, Rapid clicking when pressing start button, Loss of all accessories and instrument cluster, Warning messages about 12V system
Fix: The AGM 12V battery is tucked in the trunk and gets cycled hard by the DC-DC converter. Dies much earlier than typical ICE car batteries. Simple replacement but must be programmed to the BMS or you'll get persistent warnings. 0.5-1.0 hour labor.
Estimated cost: $250-450
Reduction Gear (Transmission) Oil Leak
Occasional · medium severity
Typical onset: 60,000-100,000 mi
Symptoms: Small oil spots under front of vehicle, Gear oil visible on drive axle seals or differential case, Whining noise from motor/transaxle during acceleration if level drops significantly
Fix: The single-speed reduction gear uses conventional gear oil and the output shaft seals can weep. Axle seal replacement requires pulling the half-shaft. If caught early it's just seals; if run low you risk damaging the planetary gears. 2-3 hours per side for axle seals.
Estimated cost: $400-800
Inverter Coolant Pump Failure
Rare · high severity
Typical onset: 80,000-120,000 mi
Symptoms: Check EV system warning with reduced power mode, Overheating warnings during highway driving or DC fast charging, Whining or grinding noise from under hood near firewall, Coolant level drops without visible external leaks
Fix: The electric coolant pump for the inverter and motor cooling loop can fail. When it does, the system goes into limp mode to prevent damage. Pump replacement requires draining the EV cooling system and proper bleeding procedure. 2-3 hours labor.
Estimated cost: $800-1,400
Charging Port Door Actuator Sticking
Occasional · low severity
Symptoms: Charge port door won't open when button is pressed, Door opens slowly or partially, Clicking noise from charge port area with no door movement, Manual release required to access charge port
Fix: The motorized charge port door mechanism gets sticky from road grime and weather exposure. Often starts as sluggish operation before failing completely. Cleaning and lubrication sometimes works, but actuator replacement is common. 1.0-1.5 hours labor.
Symptoms: Clunking or thumping noise during low-speed braking, Vibration through brake pedal during regen blending, Noise when vehicle transitions between regen and friction brakes, No loss of braking effectiveness
Fix: The integrated brake actuator that blends regenerative and friction braking can develop internal wear causing noise. It's mostly a nuisance unless it progresses to ABS/ESC faults. Some cases resolved with brake fluid flush and actuator recalibration, others need actuator replacement. 2-4 hours labor for replacement.
Estimated cost: $1,200-2,000
Owner tips
Replace the 12V battery proactively at 4-5 years regardless of mileage—it's cheap insurance against being stranded
Check reduction gear oil level at every tire rotation; it doesn't get flagged in normal service schedules
Keep the charge port door mechanism clean and lube the hinge points annually with silicone spray
If you see charging errors, test at multiple charging stations before replacing the OBCM—faulty EVSEs cause false diagnoses
I'd buy one used without hesitation—electric drivetrain issues are infrequent and far cheaper than ICE engine/trans repairs, just budget for a 12V battery and verify charging works on multiple EVSEs during pre-purchase inspection.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Unlock any single procedure for $3 — or become the founding sponsor and we generate every common job on this Ioniq Electric, with your name on each one.
Fitment notes: Auxiliary 12V battery only; electric vehicle uses high-voltage traction battery for propulsion
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2017-2019 Hyundai Ioniq Electric — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
Electric Motor Control Unit (MCU)2.5 hr R&Rdealer / factory tool +0.8 hr▸ programming details
📍 Under hood, center firewall area mounted to motor assembly
🔧 Hyundai GDS
⚠️ High-voltage system; requires HV safety lockout and insulated tools. VIN and battery pairing required.
Motor Driven Power Steering Control Unit (MDPS)1.5 hr R&Rdealer / factory tool +0.5 hr▸ programming details
📍 Steering column, under dashboard
🔧 Hyundai GDS
⚠️ Steering angle sensor calibration required after replacement.
⚠️ Sensor calibration may be required after replacement.
Telematics Control Unit / Blue Link Module (TCU)0.6 hr R&Rdealer / factory tool +0.5 hr▸ programming details
📍 Behind headliner, center roof area
🔧 Hyundai GDS
⚠️ Requires Blue Link subscription activation. VIN and account pairing needed.
Rear View Camera Module (RVC)0.5 hr R&Rno coding
📍 Integrated into rear liftgate handle
⚠️ Plug-and-play. Camera calibration lines displayed by AVN head unit.
Tire Pressure Monitoring System Receiver (TPMS)0.5 hr R&Rrelearn only +0.2 hr▸ programming details
📍 Behind lower center dashboard
🔧 TPMS relearn tool or Hyundai GDS
⚠️ Sensor IDs must be learned after replacement or tire rotation.
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
Hyundai Motor America (Hyundai) is recalling certain 2017-2019 Ioniq electric vehicles. An unstable electrical ground may cause the vehicle to enter a fail-safe mode with reduced acceleration and power. In certain conditions while in fail-safe mode, the vehicle may accelerate after the gas pedal is released.
Consequence: Unexpected acceleration following gas pedal release can increase the risk of a crash.
Remedy: Dealers will update the EPCU (Electric Power Control Unit) software and repair the ground wiring, free of charge. Owner notification letters were mailed February 9, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 215.
Fuel economy (EPA)
City
150MPGe
Highway
122MPGe
Combined
136MPGe
Fuel
Electricity
Capability & size
EPA class
Midsize Cars
Wiper blades
First generation Ioniq Electric (AE); all Ioniq variants (Electric, Hybrid, PHEV) share same wiper specifications
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2019 Hyundai Ioniq Electric Electric and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.