The 2021 Cayenne GTS with the 4.0L twin-turbo V8 is generally solid but shares the E3 platform's transmission cooling vulnerabilities and, more critically, some engines suffer from catastrophic cylinder liner/piston failures that can require full rebuilds—fortunately rarer on 2021+ models than earlier years, but the risk exists.
Symptoms: Sudden loss of compression in one or more cylinders, Severe engine knock or rattling, White or blue smoke from exhaust, oil consumption spikes, Check engine light with misfire codes
Fix: Complete engine rebuild or short block replacement required. This involves cylinder liner replacement, pistons, rings, bearings, head gaskets—essentially a ground-up engine rebuild. 40-60 labor hours at a Porsche specialist. Some cases covered under extended warranty if documented, but out-of-pocket is brutal.
Estimated cost: $25,000-45,000
Transmission Oil Cooler Leaks
Occasional · medium severity
Typical onset: 50,000-90,000 mi
Symptoms: Transmission fluid pooling under vehicle, usually passenger side, Low transmission fluid warning on dash, Burnt transmission fluid smell, Harsh or delayed shifts if fluid level drops significantly
Fix: Replace transmission oil cooler and lines, flush system. Requires removing undertray and some front-end access work. 4-6 hours labor. Catch it early before low fluid damages the 8-speed Tiptronic.
Estimated cost: $1,200-2,200
Transmission Mount Failure
Common · low severity
Typical onset: 60,000-100,000 mi
Symptoms: Clunking or thudding on hard acceleration or deceleration, Excessive drivetrain movement felt through cabin, Vibration at idle in Drive
Fix: Replace transmission mount(s)—the rear mount is the usual culprit. Requires lifting vehicle and supporting transmission. 2-3 hours labor. OEM mounts are hydraulic and wear faster with aggressive driving.
Estimated cost: $600-1,100
Fuel Filter Clogging (High-Pressure Pump Issues)
Occasional · medium severity
Typical onset: 40,000-70,000 mi
Symptoms: Long crank time before engine starts, Rough idle or hesitation under load, Limp mode or reduced power warnings, Fuel pressure fault codes
Fix: Replace high-pressure fuel filter and sometimes the pump itself if contamination occurred. Filter is part of in-tank assembly, so fuel tank drop required. 5-7 hours labor. Use top-tier fuel to minimize risk.
Estimated cost: $1,500-3,000
Active Engine Mounts Degradation
Occasional · low severity
Typical onset: 70,000-110,000 mi
Symptoms: Increased engine vibration at idle, especially in Drive, Clunking when starting or shutting off engine, Fault codes for engine mount control module
Fix: Replace failed active engine mount(s)—usually one of the three. These are electronically controlled hydraulic mounts. 3-4 hours per mount. Diagnosis requires scan tool to check mount operation.
Estimated cost: $800-1,600
Coolant Pipe Leaks (Turbo Coolant Lines)
Occasional · medium severity
Typical onset: 50,000-90,000 mi
Symptoms: Coolant smell in cabin or under hood, Low coolant warning light, Visible coolant seepage near turbochargers, Steam from engine bay in severe cases
Fix: Replace failed turbo coolant lines or pipe connections. Access is tight—often requires removing intake components or partial turbo access work. 4-6 hours labor depending on which line fails.
Estimated cost: $1,000-2,000
Owner tips
Use factory-spec 0W-40 oil and change every 5,000 miles max—the twin-turbo V8 runs hot and demands good oil
Check transmission fluid level and condition every 30,000 miles; despite 'lifetime fill' claims, fluid degrades
Inspect coolant pipes and transmission cooler lines annually for seepage—catching leaks early saves major repairs
Avoid extended idle periods in hot weather; these engines heat-soak and stress cooling components
If buying used, verify no open recalls and request engine compression test—cylinder liner issues show up as low compression
Buy a 2021+ with full service records and a pre-purchase inspection focusing on compression test and transmission health—most are bulletproof, but the rare engine failure is financially devastating.
AI-assisted summary drawn from NHTSA recall data, our labor-times database, and platform knowledge. Not a substitute for a pre-purchase inspection on a specific vehicle.
Fitment notes: AGM battery required; located under cargo floor in rear
As an Amazon Associate, OLP earns from qualifying purchases — how we link. This never changes the specs we publish.
Every control module on the 2018-2022 Porsche Cayenne GTS — where it lives, replacement time, and what it takes to program a replacement. Modules marked dealer / factory tool won't work after a part swap alone — budget for programming.
Power Steering Control Unit / Electromechanical Power Steering (EPS)3.5 hr R&Rdealer / factory tool +0.6 hr▸ programming details
📍 Steering column, integrated with steering rack assembly
🔧 PIWIS III
⚠️ Rear-axle steering available on some GTS models. Requires steering angle sensor calibration and end-stop learning.
Transmission Control Unit (TCU)2.5 hr R&Rsecurity gateway +0.8 hr▸ programming details
📍 Transmission housing, driver side, accessed from underneath
🔧 PIWIS III + PPN online
⚠️ Integrated with valve body on 8-speed Tiptronic S. Requires transmission adaptation and shift point learning.
Seat Memory Control Unit (SMC)0.7 hr R&Raftermarket tool +0.2 hr▸ programming details
📍 Driver seat base, under seat trim
🔧 PIWIS III or Autel MaxiSys Elite
⚠️ 18-way power seats on GTS. Requires seat position learning and memory function adaptation.
Aftermarket tool coverage varies by software version and vehicle build — treat "aftermarket tool" rows as "usually possible" and verify against your tool maker's coverage list before promising a customer. Spot a wrong location or hour? Tell us — corrections ship fast here.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · 25V896000
2025-12-19
Porsche Cars North America, Inc. (Porsche) is recalling certain 2019-2025 Cayenne, Cayenne E-Hybrid, 2020-2025 911, Taycan, 2024-2025 Panamera, and 2025 Panamera E-Hybrid vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A rearview image that does not display properly reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the driver assistance software, free of charge. Owner notification letters were mailed February 13, 2026. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ASB2. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 19, 2026.
SUSPENSION:REAR · 22V040000
2022-01-28
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021-2022 Cayenne vehicles. The rear axle alignment may not have been inspected after the repairs for Recall 21V-271 (AMA9) were performed.
Consequence: Rear axle misalignment may cause premature or uneven tire wear, increasing the risk of a crash.
Remedy: Dealers will inspect the rear axle, adjust the alignment as necessary, and replace any prematurely or unevenly worn tires, free of charge. Owner notification letters were mailed March 10, 2022. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ANA1.
STEERING:COLUMN · 21V493000
2021-06-30
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Cayenne vehicles. The screw connection between the steering column and steering box may fail, which can result in a detached steering column.
Consequence: A detached steering column can cause a loss of control, increasing the risk of a crash.
Remedy: Dealers will install a new screw, free of charge. Owner notification letters were mailed August 24, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB4.
ENGINE · 21V341000
2021-05-12
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Cayenne Turbo, Cayenne GTS, and Cayenne GTS Coupe vehicles. Cracks may develop on the surface of the engine cylinder bore.
Consequence: Cracks may cause engine damage and a stall or an oil leak, increasing the risk of a crash or fire.
Remedy: Dealers will replace the engine, free of charge. Owner notification letters were mailed July 9, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB1.
SEATS · 21V318000
2021-05-05
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Cayenne GTS, Cayenne GTS Coupe, 2020-2021 Cayenne Coupe, Cayenne S Coupe, Cayenne E-Hybrid Coupe vehicles. The passenger seat back heating element was not installed and may impact the calibration of the Occupant Classification System.
Consequence: The front passenger air bag may fail to deploy, increasing the risk of injury.
Remedy: Dealers will install a heating element, free of charge. Owner notification letters were mailed June 25, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB0.
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Cayenne, Cayenne S, Cayenne Turbo, Cayenne GTS, Cayenne Coupe, Cayenne S Coupe, Cayenne Turbo Coupe, and Cayenne GTS Coupe vehicles. The lock nut on the trailing arm of the rear axle may break due to stress corrosion.
Consequence: A broken lock nut may misalign the rear axle, causing a loss of control and increasing the risk of a crash.
Remedy: Porsche will notify owners, and dealers will replace the lock nuts, free of charge. The recall began on June 18, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMA9.
Performance
Horsepower
453hp
Torque
457lb-ft
0–60 mph
4.2sec
Quarter mile
12.7sec
Top speed
168mph
Fuel economy (EPA)
City
15mpg
Highway
19mpg
Combined
17mpg
Fuel
Premium Gasoline
Capability & size
Towing capacity
7,716lb
Payload
1,212lb
Curb weight
4,938lb
EPA class
Standard Sport Utility Vehicle 4WD
Wiper blades
2018-2023 Cayenne GTS (E3 generation). Standard hook attachment for all positions.
Size-standard part numbers — verify your connector type before buying. Rear blades are model-specific; check the package's vehicle list.
Fuel economy figures are EPA data via fueleconomy.gov (median across matching trims). Performance figures are compiled estimates for the 2021 Porsche Cayenne GTS 4.0L Twin Turbo V8 and can vary by trim.
🔧 Database maintained under the daily editorial review of Chris Hackleman · Master Technician · 20+ years and Jeff Moore · Master Lexus & Toyota Mechanic · 20+ years.